1999 Nissan Altima Se Sedan 4-door 2.4l on 2040-cars

Auto blog

DC fast charging not as damaging to EV batteries as expected

As convenient as DC fast charging is, there have been lots of warnings that repeated dumping of so many electrons into an electric vehicle's battery pack in such a short time would reduce the battery's life. While everyone agrees that DC fast charging does have some effect on battery life, it may not be as bad as previously expected. Over on SimanaitisSays, Dennis Simanaitis, writes about a recent presentation by Matt Shirk of the Idaho National Laboratory (INL) called DC Fast, Wireless, And Conductive Charging Evaluation Projects (PDF) that describes an ongoing test of four 2012 Nissan Leaf EVs that are being charged in two pairs of two. One pair only recharges from 50-kW DC fast chargers, which the other two sip from 3.3-kW Level 2 chargers exclusively. Otherwise, the cars are operated pretty much the same: climate is automatically set to 72 degrees, are driven on public roads around Phoenix, AZ and have the same set of dedicated drivers is rotated through the four cars. "Degradation depends more on the miles traveled than on the nature of recharging." What's most interesting are the charts on page seven of Shirk's presentation (click the image above to enlarge), which show the energy capacity of each of the four vehicles. When they were new, the four batteries were each tested to measure their energy capacity and given a 0 capacity loss baseline. They were then tested at 10,000, 20,000, 30,000 and 40,000 miles, and at each point, the DC-only EVs had roughly the same amount of battery loss as the Level 2 test subjects. The DC cars did lose a bit more at each test, but only around a 25-percent overall loss after 40k, compared to 23 percent for the Level 2 cars. Simanaitis' takeaway is that, "INL data suggest that the amount of degradation depends more on the miles traveled than on the nature of recharging." The tests are part of the INLs' Advanced Vehicle Testing Activity work and a final report is forthcoming. These initial numbers from IPL do mesh with other research into DC fast charging, though. Mitsubishi said daily fast charging wouldn't really hurt the battery in the i-MiEV and MIT tests of a Fisker Karma battery showed just 10-percent loss over 1,500 rapid charge-discharge cycles.

Nissan adds 500 jobs in Mississippi for Murano production [w/video]

Nissan is bolstering its workforce at its Canton, MS factory, adding 500 workers for this fall's production kickoff of the heavily redesigned Murano crossover.
"The addition of Murano to our portfolio, coupled with the continued growth and success of the Canton plant, will move us even closer to our goal to build more than 85 percent of the vehicles we sell in the US right here in North America," said senior vice president of manufacturing, supply chain management and purchasing for Nissan's North American ops, John Martin.
The Murano will eventually be exported to over 100 markets and will be built alongside the current Xterra, Frontier, Titan and Armada. The addition of 500 jobs to the Canton facility elevates its total workforce past 6,000 people.

Nissan recalling 2012-14 Frontier pickups over fire risk

Nissan is recalling its Frontier pickup over fire concerns, according to a National Highway Traffic Safety Administration bulletin. A total of 13,535 vehicles are being recalled, all from the 2012 to 2014 model years, built between November 28, 2012 and December 27, 2013.
The NHTSA report states that "in the affected vehicles, a circuit breaker may have been installed incorrectly causing the main wire harness connected to the circuit breaker to face outward, potentially contacting a metal bolt located on the A-pillar." If this happens, it's possible that "the bolt may wear though the wire harness covering, resulting in an electrical short," NHTSA states. In the event of an electric short, a fire may occur.
The official recall will begin in March, where Nissan dealers will inspect the circuit breaker for the correct orientation, and if necessary, repair the vehicles, free of charge. Scroll down for the full NHTSA bulletin.