2009 Nissan 370z Touring Automatic Htd Leather Nav 46k Texas Direct Auto on 2040-cars

Auto blog

DC fast charging not as damaging to EV batteries as expected

As convenient as DC fast charging is, there have been lots of warnings that repeated dumping of so many electrons into an electric vehicle's battery pack in such a short time would reduce the battery's life. While everyone agrees that DC fast charging does have some effect on battery life, it may not be as bad as previously expected. Over on SimanaitisSays, Dennis Simanaitis, writes about a recent presentation by Matt Shirk of the Idaho National Laboratory (INL) called DC Fast, Wireless, And Conductive Charging Evaluation Projects (PDF) that describes an ongoing test of four 2012 Nissan Leaf EVs that are being charged in two pairs of two. One pair only recharges from 50-kW DC fast chargers, which the other two sip from 3.3-kW Level 2 chargers exclusively. Otherwise, the cars are operated pretty much the same: climate is automatically set to 72 degrees, are driven on public roads around Phoenix, AZ and have the same set of dedicated drivers is rotated through the four cars. "Degradation depends more on the miles traveled than on the nature of recharging." What's most interesting are the charts on page seven of Shirk's presentation (click the image above to enlarge), which show the energy capacity of each of the four vehicles. When they were new, the four batteries were each tested to measure their energy capacity and given a 0 capacity loss baseline. They were then tested at 10,000, 20,000, 30,000 and 40,000 miles, and at each point, the DC-only EVs had roughly the same amount of battery loss as the Level 2 test subjects. The DC cars did lose a bit more at each test, but only around a 25-percent overall loss after 40k, compared to 23 percent for the Level 2 cars. Simanaitis' takeaway is that, "INL data suggest that the amount of degradation depends more on the miles traveled than on the nature of recharging." The tests are part of the INLs' Advanced Vehicle Testing Activity work and a final report is forthcoming. These initial numbers from IPL do mesh with other research into DC fast charging, though. Mitsubishi said daily fast charging wouldn't really hurt the battery in the i-MiEV and MIT tests of a Fisker Karma battery showed just 10-percent loss over 1,500 rapid charge-discharge cycles.

GM, UAW poaching Nissan workers in Tennessee

General Motors and the United Auto Workers are going on a recruitment drive at the Spring Hill factory in Tennessee, and they're hoping to poach some skilled workers from Nissan's nearby plant in Smyrna, TN. The General and the union even bought a billboard advertising for industrial electricians near the Japanese automaker's facility, according to the Daily News Journal. The reason for the billboard was simple. "GM was short of electricians," said Tim Stannard, the president of the UAW local at Spring Hill, to the Daily News Journal. The factory currently builds the Chevrolet Equinox but has a contract to assemble the next generation of Ecotec engines and the Cadillac XT5, which replaces the SRX. Thanks to the $185-million deal, employment there is expected to double by May 2016, according to Stannard, with roughly 1,800 additional union jobs. Beyond just several billboards, GM has job postings online for the Spring Hill plant looking for workers with specific skills. There has already been some interest in the positions among Nissan employees, Stannard indicated. According to a recent study by the Center for Automotive Research, the average GM worker currently makes $58 an hour, including benefits. Comparatively, Nissan pays an average of $42 an hour with benefits. The General's number could change in the coming weeks because its contract with the UAW is about to expire, and higher wages are among the major negotiating points.

Chevy Volt sales drop in June, Nissan Leaf inches upwards

Different month, same story. That's the gist of the monthly US sales numbers from the Chevy Volt and the Nissan Leaf. These were the first two mass-market plug-in vehicles to go on sale in the US and we've been comparing their sales numbers for what seems like ages now. So far, the 2014 tale of the tape shows the all-electric once again trumping the plug-in hybrid. The last time the Volt outsold the Leaf was in October 2013. Chevrolet sold 1,777 Volts in June. That was good enough to be the Volt's best sales month of the year, but it's down 34 percent from the 2,698 units sold in June 2013. In fact, it's on par with the 1,760 Volts sold in June 2012. Given the steady sales, General Motors might need to push up the release of the next-gen Volt to gin up excitement, especially if it also offers some of the things that current Volt drivers say they want improved: more range, a lower price and a fifth seat. GM also said it sold 85 Spark EVs in June, an increase of 215 percent over June 2013 Nissan sold 2,347 Leafs last month. The good news continues for Nissan, which says it sold 2,347 Leafs last month. That's an increase of 5.5 percent over 2013 numbers and makes 2014 the best June ever for Leaf sales. Let's credit Texas. Toby Perry, Nissan's director of EV sales and marketing, said in a statement that, "Since the Texas state incentive went into effect in May, we've seen a big jump in Leaf sales in the Austin, Dallas and Houston markets. Our dealers are telling us that they saw more traffic in their stores, and they had their best Leaf sales performance in the last weekend in June." Even with that increase, Atlanta remains the top Leaf market. Nissan has sold 12,736 Leafs in the US so far this year; Chevy 8,615 Volts. Our detailed monthly sales write-up of green cars in the US, including plug-in vehicles, hybrids and diesel cars, is coming soon. For now, we invite you to discuss these numbers in the Comments. Related Gallery 2013 Nissan Leaf View 55 Photos News Source: GM, Nissan Green Chevrolet Nissan Electric Hybrid PHEV ev sales