1986 Nissan 300zx on 2040-cars

Auto blog

DC fast charging not as damaging to EV batteries as expected

As convenient as DC fast charging is, there have been lots of warnings that repeated dumping of so many electrons into an electric vehicle's battery pack in such a short time would reduce the battery's life. While everyone agrees that DC fast charging does have some effect on battery life, it may not be as bad as previously expected. Over on SimanaitisSays, Dennis Simanaitis, writes about a recent presentation by Matt Shirk of the Idaho National Laboratory (INL) called DC Fast, Wireless, And Conductive Charging Evaluation Projects (PDF) that describes an ongoing test of four 2012 Nissan Leaf EVs that are being charged in two pairs of two. One pair only recharges from 50-kW DC fast chargers, which the other two sip from 3.3-kW Level 2 chargers exclusively. Otherwise, the cars are operated pretty much the same: climate is automatically set to 72 degrees, are driven on public roads around Phoenix, AZ and have the same set of dedicated drivers is rotated through the four cars. "Degradation depends more on the miles traveled than on the nature of recharging." What's most interesting are the charts on page seven of Shirk's presentation (click the image above to enlarge), which show the energy capacity of each of the four vehicles. When they were new, the four batteries were each tested to measure their energy capacity and given a 0 capacity loss baseline. They were then tested at 10,000, 20,000, 30,000 and 40,000 miles, and at each point, the DC-only EVs had roughly the same amount of battery loss as the Level 2 test subjects. The DC cars did lose a bit more at each test, but only around a 25-percent overall loss after 40k, compared to 23 percent for the Level 2 cars. Simanaitis' takeaway is that, "INL data suggest that the amount of degradation depends more on the miles traveled than on the nature of recharging." The tests are part of the INLs' Advanced Vehicle Testing Activity work and a final report is forthcoming. These initial numbers from IPL do mesh with other research into DC fast charging, though. Mitsubishi said daily fast charging wouldn't really hurt the battery in the i-MiEV and MIT tests of a Fisker Karma battery showed just 10-percent loss over 1,500 rapid charge-discharge cycles.

200 Nissan Leafs recalled for faulty power inverters

Nissan is going full speed ahead with strong sales for its all-electric Leaf. Unfortunately, some of those Leafs had a glitch that could stop some of those Leafs from doing the same. Credit a faulty power inverter. US Department of Transportation says the faulty power inverters may cause some Leafs to shut down unexpectedly. Thankfully, the glitch affects just 196 Leafs, all of which were produced between April 15 and 24, 2014. Official DOT information on the recall is available here and it's also pasted below. Nissan started contacting Leaf owners in late May, instructing them to bring their vehicles to certified Leaf dealers for repairs, Nissan spokesman Brian Brockman told AutoblogGreen, adding that there'd been no cases of vehicle shut downs from the power inverter. Nissan confirmed the 196-vehicle figure and isn't charging the vehicle owners for the repairs. The company is also providing loaner vehicles at no cost. The recall marks a rare bit of bad news for Nissan's electrification efforts, as the Japanese automaker has been boosting sales of the Leaf all year. Through May, Leaf sales in the US were up 36 percent from a year earlier to 10,389 units, and May sales alone had surged 46 percent from a year earlier. In May, Chrysler recalled more than 4,141 Fiat 500e models from the 2013 and 2014 model years for a similar issue. Inverter modules on those vehicles may allow coolant to seep onto electrical components, which could cause a short circuit and power loss. The recall impacted cars built between September 2012 and April 2014. Report Receipt Date: MAY 16, 2014 NHTSA Campaign Number: 14V263000 Potential Number of Units Affected: 196 Manufacturer: Nissan North America, Inc. SUMMARY: Nissan North America, Inc. (Nissan) is recalling certain model year 2014 Nissan LEAF vehicles manufactured April 15, 2014, through April 24, 2014. Due to a problem with the motor control circuit board, the inverter may fail, causing the vehicle shut down. CONSEQUENCE: An unexpected vehicle shut down increases the risk of a crash. REMEDY: Nissan will notify owners, and dealers will replace the inverter, free of charge. The recall is expected to begin on July 7, 2014. Owners may contact Nissan customer service at 1-800-647-7261. NOTES: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

2013 Nissan NV200

Moving is not fun. On the scale of adult activities, it ranks somewhere between taxes and jury duty. Boxes need to be loaded, furniture needs to be lifted and the entire affair is typically fueled by a combination of pizza, beer and pain killers (a combo my friends affectionately refer to as "moving fuel"). It's not fun, and it's rarely easy.
While it doesn't make the activity any more enjoyable, having the right vehicle for the job is the difference between loading and unloading half a dozen times and doing it once or twice. When taken as a whole, a proper moving van can shave hours off a day of labor, not to mention untold years of physical and mental stress for those who must take to their wheels every day.
That truism was borne out once again when I borrowed a loaded Nissan NV200 SV to help my girlfriend move into her new house. The little Nissan was a comfortable and able companion throughout the day, managing everything from a mattress and box springs to countless boxes of clothes, dishes and other necessities. Throughout the day, the NV impressed not just with the amount of stuff it could fit in its cavernous back end, but with the features it had to make moving anything easier.