1985 Nissan 300zx on 2040-cars

Auto blog

DC fast charging not as damaging to EV batteries as expected

As convenient as DC fast charging is, there have been lots of warnings that repeated dumping of so many electrons into an electric vehicle's battery pack in such a short time would reduce the battery's life. While everyone agrees that DC fast charging does have some effect on battery life, it may not be as bad as previously expected. Over on SimanaitisSays, Dennis Simanaitis, writes about a recent presentation by Matt Shirk of the Idaho National Laboratory (INL) called DC Fast, Wireless, And Conductive Charging Evaluation Projects (PDF) that describes an ongoing test of four 2012 Nissan Leaf EVs that are being charged in two pairs of two. One pair only recharges from 50-kW DC fast chargers, which the other two sip from 3.3-kW Level 2 chargers exclusively. Otherwise, the cars are operated pretty much the same: climate is automatically set to 72 degrees, are driven on public roads around Phoenix, AZ and have the same set of dedicated drivers is rotated through the four cars. "Degradation depends more on the miles traveled than on the nature of recharging." What's most interesting are the charts on page seven of Shirk's presentation (click the image above to enlarge), which show the energy capacity of each of the four vehicles. When they were new, the four batteries were each tested to measure their energy capacity and given a 0 capacity loss baseline. They were then tested at 10,000, 20,000, 30,000 and 40,000 miles, and at each point, the DC-only EVs had roughly the same amount of battery loss as the Level 2 test subjects. The DC cars did lose a bit more at each test, but only around a 25-percent overall loss after 40k, compared to 23 percent for the Level 2 cars. Simanaitis' takeaway is that, "INL data suggest that the amount of degradation depends more on the miles traveled than on the nature of recharging." The tests are part of the INLs' Advanced Vehicle Testing Activity work and a final report is forthcoming. These initial numbers from IPL do mesh with other research into DC fast charging, though. Mitsubishi said daily fast charging wouldn't really hurt the battery in the i-MiEV and MIT tests of a Fisker Karma battery showed just 10-percent loss over 1,500 rapid charge-discharge cycles.

10 automakers shack up in Detroit hotel to talk Takata airbags

Since Takata has decided not to take the lead concerning potential issues with its airbag inflators, the automakers have. Perhaps that's unsurprising, since it's the automakers, not Takata, that will take a beating on the dealership floor if consumers decide its models are a health hazards. The Detroit News reports that Toyota, Honda, General Motors, Ford, Chrysler, Mazda, BMW, Nissan, Mitsubishi and Subaru met in a hotel conference room near the Detroit Metropolitan Airport last week to sort out a way to understand the technical issues involved. So far, faulty airbag inflators have been ruled the cause of five deaths and 50 injuries around the world, but neither Takata nor investigators understands exactly why the inflators are malfunctioning. The National Highway Traffic Safety Administration recently asked Takata to issue a national recall, Takata declined, citing a minuscule failure rate and the fact that it's still investigating the issue. Toyota and Honda then made an industry-wide appeal for "a coordinated, comprehensive testing program" that would pinpoint the problem inflators and get them replaced, and that's what the Detroit meeting was about. Numerous issues, however, will make this a long row to hoe: simply getting the parts to replace the nearly 20 million inflators in cars recalled around the world so far - even working with other suppliers - will take a years, but more importantly, no one knows if the replacement inflators currently being installed will suffer the same issue. Answers will hopefully come quickly with Takata, the ten automakers and NHTSA all independently investigating the problem.

US-built Infiniti Q50 engines to go into Euro-only cars

Back in March, Infiniti announced that it would be adding a 2.0-liter, turbocharged four-cylinder to its Q50 line for European and Chinese buyers. Now, we know where that engine will be built.
Nissan's Decherd, TN facility will receive the $319-million investment, which will see a separate, dedicated line for the Infiniti engines. According to Automotive News, this is more than a line running alongside the Nissan operations - the Infiniti facility will sport its own unique architecture and interior lighting, in a bid to distinguish the premium line from its mass-market parent company.
The logistics of all this do seem, on the surface, quite screwy. Building a new engine on one continent for a car built on another that will eventually go on sale on a third doesn't seem too bright, although there is a catch here. The new engine will also find its way into the Mercedes-Benz C-Class, which will kick off production in Vance, AL later this year.