1965 Mercury Marauder Marauder on 2040-cars

Auto blog

Ford finds flex-fuel engine design plays big role in emissions output

How bad is ethanol for your engine? There's been a lot of debate on this issue as the US considers upping the biofuel content in the national gasoline supply from 10 percent (E10) to 15 percent (E15). The ethanol industry and some scientists say higher ethanol blends show no "meaningful differences" in new engines while the oil industry says ethanol creates health risks. Researchers working at the Ford Research and Innovation Center decided to take a closer look at how a wide range of gas-ethanol blends - E0, E10, E20, E30, E40, E55 and E80 - affected the emissions coming out of a flex-fuel 2006 Mercury Grand Marquis. To see the full report, printed in the journal Environmental Science & Technology, requires payment, but there is an abstract and Green Car Congress has some more details. The gist is that, "with increasing ethanol content in the fuel, the tailpipe emissions of ethanol, acetaldehyde, formaldehyde, methane, and ammonia increased." At least NOx and NMHC emissions decreased. The researchers say that the effects are due to the fuel and "are expected for all FFVs," but that the way that a manufacturer calibrates the engine will affect NOx, THC, and NMOG emissions. It's this last bit that's important, since the researchers found, "Higher ethanol content in gasoline affects several fundamental fuel properties that can impact emissions. ... These changes can have positive or negative effects that can depend on engine design, hardware, and control strategy. In addition to direct emissions impacts, higher ethanol content fuel can also provide more efficient combustion and overall engine operation under part-load conditions and under knock-limited higher-load conditions." So, as we head towards more ethanol in our fuel supply (maybe), manufacturers are going to need to learn how to burn it most efficiently.

Junkyard Gem: 1981 Mercury Cougar XR-7

The story of the Mercury Cougar involves more plot twists and unexpected digressions than that of just about any other Detroit car, with successive Cougar generations based on the Ford Mustang (1967-1973), the Ford Torino and/or Thunderbird (1974-1979), various Fox Fords including the Thunderbird (1980-1988), the MN12 Thunderbird/Lincoln Mark VIII (1989-1997), and the Ford Mondeo (1999-2002). There were wagon and sedan Cougars for brief periods, just to confuse everybody, and the rakish XR-7 Cougars sometimes lived on different platforms from their ordinary non-XR-7 counterparts. I think the Late Malaise Era Fox XR-7s are among the most interesting of the bunch, so I was quite excited to spot this tan-over-gold '81 in a Denver yard. I tried to count the number of screaming-cat badges on and in this car and gave up once I hit a dozen. The steering wheel, door panels, C pillars, center console, and — of course — the hood ornament all boast snarling felines. Earlier Cougars had emblems showing full side views of stalking catamounts, but the Cougar logo for the 1980s showed just the head. This car got the optional center console, which I hear is quite a rarity. You had to pay $174 extra (that's around $513 in 2020 dollars) for an AM/FM/cassette audio system in the '81 Cougar, but at least the air conditioning was standard equipment. Believe it or not, thieves used to steal these radios. Kumpf Lincoln-Mercury still exists in Englewood (as Landmark Lincoln), and the yard that now houses this car can be found just 15 miles up Broadway on the north side of Denver.  The padded landau roof hasn't fared so well beneath the fierce Colorado sun, but overall this car seems very solid. Sadly, only the Mustangs and (once in a long while) Fairmonts get much love from the Fox Ford crowd these days. Three Mercury "wire wheel" hubcaps and one from a Lincoln. The base engine in the 1981 XR-7 was the "Thriftmaster" 200-cubic-inch (3.3-liter) straight-six, but very few XR-7 buyers would have refrained from checking the box for one of the two optional Windsor V8s. I can't tell if we're looking at the 255-cubic-inch (4.2-liter) version or the 302-cubic-inch (5.0-liter) one here, but real-world drivers might not have noticed the difference between the 120-horse 255 and the 130-horse 302, anyway. The non-XR-7 Fox Cougars had five-speed manual transmissions as base equipment (which nobody wanted), but all 1981 XR-7s had automatics.

Ford recalls over 953,000 vehicles to replace Takata airbag inflators

DETROIT — Ford is recalling more than 953,000 vehicles worldwide to replace Takata passenger airbag inflators that can explode and hurl shrapnel. The move includes over 782,000 vehicles in the U.S. and is part of the largest series of recalls in U.S. history. Included are the 2010 Ford Edge and Lincoln MKX, the 2010 and 2011 Ford Ranger, the 2010 to 2012 Ford Fusion and Lincoln MKZ, the 2010 and 2011 Mercury Milan, and the 2010 to 2014 Ford Mustang. Some of the recalls may be limited to specific geographic areas of the U.S. Takata used the chemical ammonium nitrate to create an explosion to inflate airbags. But it can deteriorate over time due to heat and humidity and explode with too much force, blowing apart a metal canister designed to contain the explosion. At least 23 people have been killed worldwide and hundreds injured by the inflators. Ford says it doesn't know of any injuries in vehicles included in this recall. Dealers will replace the inflators. Ford will notify owners about the recall starting on Feb. 18, and the company has replacement parts available for dealers to order, said spokeswoman Monique Brentley. In previous Takata recalls, parts availability had been an issue. Owners can go to this Ford website and key in their vehicle identification number to see if their cars and SUVs are being recalled. The same information will be available soon at the NHTSA recall website. More than three years after the U.S. National Highway Traffic Safety Administration took over management of recalls involving Takata inflators, one third of the recalled inflators still have not been replaced, according to an annual report from the government and a court-appointed monitor. The report says 16.7 million faulty inflators out of 50 million under recall have yet to be replaced. And 10 million more inflators are scheduled to be recalled this month, including the Ford vehicles. Safety advocates said the completion rate should be far higher given the danger associated with the inflators. The recalls forced Takata of Japan to seek bankruptcy protection and sell most of its assets to pay for the fixes. The inflators grow more dangerous as they get older because ammonium nitrate deteriorates due to high humidity and cycles from hot temperatures to cold. The most dangerous inflators are in areas of the South along the Gulf of Mexico that have high humidity. Related Video: