2007 Mercedes- Benz Gl 320 Diesel on 2040-cars

Auto blog

Mercedes-Benz engines with 48-volt systems coming in 2017

As part of a big green push announced yesterday, Mercedes-Benz is jumping into the world of 48-volt power. The company will launch a new family of efficient gasoline engines next year and will begin rolling out 48-volt systems with it, likely in its more expensive cars first. Mercedes will use the 48-volt systems to power mild-hybrid functions like energy recuperation (commonly called brake regeneration), engine stop-start, electric boost, and even moving a car from a stop on electric power alone. These features will be enabled through either an integrated starter-generator (Mercedes abbreviates it ISG) or a belt-driven generator (RSG). (RSG is from the German word for belt-driven generator, Riemenstartergeneratoren. That's your language lesson for the day.) Mercedes didn't offer many other details on the new family of engines. There are 48-volt systems already in production; Audi's three-compressor SQ7 engine uses an electric supercharger run by a 48-volt system, and there's a new SQ5 diesel on the horizon that will use a similar setup with the medium-voltage system. Electric superchargers require a lot of juice, which can be fed by either a supercapacitor or batteries in a 48-volt system. Why 48-volt Matters: Current hybrid and battery-electric vehicles make use of very high voltages in their batteries, motors, and the wiring that connects them, usually around 200 to 600 volts. The high voltage gives them enough power to move a big vehicle, but it also creates safety issues. The way to mitigate those safety issues is with added equipment, and that increases both cost and weight. You can see where this is going. By switching to a 48-volt system, the high-voltage issues go away and the electrical architecture benefits from four times the voltage of a normal vehicle system and uses the same current, providing four times the power. The electrical architecture will cost more than a 12-volt system but less than the complex and more dangerous systems in current electrified vehicles. The added cost makes sense now because automakers are running out of ways to wisely spend money for efficiency gains. Cars can retain a cheaper 12-volt battery for lower-power accessories and run the high-draw systems on the 48-volt circuit. The industry is moving toward 48-volt power, with the SAE working on a standard for the systems and Delphi claiming a 10-percent increase in fuel economy for cars that make the switch.

Recharge Wrap-up: Honda FCV Concept comes to Detroit, Toyota seeks young green energy fellows

Honda will bring its FCV Concept to the 2015 North American International Auto Show in Detroit in January. The hydrogen-powered concept made its Japanese debut in November, and will now make its way to North America for the first time. The FCV concept improves upon the design of the FCX Clarity with a more striking appearance and roomier interior. Its smaller powertrain packaging means more space for people, and the FCV Concept seats five passengers. Honda also expects the next-generation fuel-cell car, which is scheduled to go on sale in Japan in March 2016, to cost less and have a range of over 300 miles. Read more in the press release below. The Mercedes-Benz B-Class Electric Drive has been awarded an environmental certificate from the TUV Sud technical inspection authority. The certificate is based not just on the vehicle's operation, but the entire lifecycle of the car, including production and recycling. The B-Class Electric Drive produces 24 percent less CO2 over its lifecycle than the Mercedes-Benz B180 when using the EU electricity mix, and 64 percent less when powered by hydroelectricity. Mercedes credits not just the use of electricity, but also the car's energy management system - such as its radar-based regenerative braking - for its carbon reductions. Read more in the press release below. Scania will test a wirelessly charged plug-in hybrid bus in Sweden. Beginning in June 2016, the bus will be put to daily use in Sodertalje. One of its stops will have a wireless charging station where the bus will recharge for six to seven minutes before continuing on its route again. The charger is located under the road surface and the bus positions itself above it to charge inductively. About $1.3 million will come from the Swedish Energy Agency to fund the test project, which could save up to 90 percent of fuel costs. If expanded to a fleet of 2,000 buses, it could save up to 13 million gallons of fuel each year. Read more at Green Car Congress, and in the press release below. Sandia National Laboratories and Linde are teaming up to expand hydrogen fueling infrastructure. The two groups have signed an agreement to research and develop new hydrogen stations, as well as ways to make fuel cell vehicles more desirable for consumers. They are looking at ways to incorporate hydrogen into existing fuel stations where possible, and make sure that it is able to be done safely.

Daimler and Volvo could jointly develop internal combustion engines

BERLIN — Luxury German carmaker Daimler and Volvo, owned by China's Geely, are considering cooperating to cut the costs of developing combustion engines, a magazine reported on Sunday, citing unnamed company sources. The Automobilwoche weekly cited a Volvo manager as saying there were initial talks with Daimler, but no concrete plans, while a company spokesman said it was too early to talk about firm projects, although it was not excluding anybody. A Daimler spokesman said the company's cooperation with Geely, which owns a 10% stake in the German carmaker, was developing in a positive way, but declined to comment further. Global tariffs, accelerated by a trade war between China and the United States, as well as higher investment requirements for electric and autonomous vehicles, are forcing carmakers to seek new ways to cut and share costs. In October, Volvo said it would merge its engine development and manufacturing assets with those of Geely, creating a division to supply in-house brands and also potentially others with next-generation combustion and hybrid engines. Automobilwoche said this new division would start operating by the end of March, which could be a possible starting point for cooperation with Daimler, while a further step could be a partnership to develop electric power trains. Geely and Daimler have said they plan to build the next generation of Smart electric cars in China through a joint venture and the two companies are also cooperating on a premium ride-hailing service in China. Geely bought Volvo Cars in 2010 from Ford, allowing the Swedish brand to operate on an arms-length basis. But in recent years, it has deepened cooperation between the two brands. Volvo already supplies engines to some Geely-branded vehicles, sharing technology through Geely's Lynk brand. Both companies share and develop common vehicle platforms. Related Video: This content is hosted by a third party. To view it, please update your privacy preferences. Manage Settings.