on 2040-cars

Auto blog

Why Mazda did so well and Volvo so poorly in Consumer Reports survey

The poor performances of Tesla and all three domestic automakers got the headlines in Consumer Reports magazine's latest reliability survey, but there were other results that caught our interest. Tiny Mazda notched the biggest gain among the 29 brands included in this year's list, leap-frogging nine spots to No. 3. Buick, which was in the top 10 last year, fell 11 spots to No. 19, the biggest decline of any brand. And then there's Volvo, a brand often vaunted for its quality and reliability, dropping six spots to dead last. What gives? For starters, all three brands benefited or suffered in large part due to their relatively small portfolio of vehicles. So when raves or complaints rolled in for even one particular model, as was often the case, it weighed heavily on the entire brand. That's especially true when it involves a relatively high-volume, hot-selling model such as the Buick Enclave (more on that in a moment). Mazda fared as well as it did despite the CX-3 losing Consumer Reports' influential "recommended" status due to problems with its climate system, including leaks from the condenser and refrigerant unit that triggered a service bulletin from the automaker in late 2016. Deputy auto editor Jon Linkov said that scratch didn't hurt the overall brand, since the CX-9 crossover and MX-5 Miata both jumped up to replace it on CR's list of newly recommended vehicles, thanks to several back fixes Mazda made to both models. For Buick, the redesigned Enclave SUV earned a "Much Worse Than Average" rating after owners reported problems with the new nine-speed automatic transmission it shares with the Chevrolet Traverse as well as some issues with the climate system. There were issues with rough shifting, plus complaints about the torque converter that necessitated fixes to the computer or outright replacement. "Again, similar stuff that we saw with the Traverse: both first-year vehicles, similar powertrains," LInkov said. He said all-new vehicles or redesigns typically fare poorly in CR's reliability survey due to issues that are hard to suss out before vehicles go into everyday use by consumers. The top-selling Encore and Envision fared well, Linkov said, but were outdone by the Enclave's problematic transmission components. The Enclave was Buick's second best-selling model through September at 35,227 units. Then there is Volvo, about which there is one word to sum up its woes: infotainment.

Mazda halts Mazda3 sales for fuel tank problem

Mazda is issuing a stop sale and recall on 14,406 examples of the 2015-2016 Mazda3 in the US with build dates between May 21, 2015, and August 24, 2015, due to a possible fuel leak. There are no reports or accidents or injuries from this problem. According to the company, a defective fuel shut-off valve can allow gasoline to move from the tank and fill the charcoal emissions canister. If it gets too full, there can be a leak, which obviously carries the risk of a possible fire. The engine might stall, as well. Affected owners will be notified to bring their Mazda3 in "as soon as possible." Dealers will inspect the vehicles, and if a problem is found, the fuel tank and charcoal emissions canister will be replaced. During the downtime, customers will get a free rental or loaner car, as well. Those who are particularly concerned can also call Mazda roadside assistance to have their vehicle delivered for the check and possible repair. Related Video: Mazda Issues Stop Sale and Stop Delivery for Mazda3 Fuel Tank Recall WASHINGTON, DC (October 2, 2015) – Mazda Motor Corporation will conduct a Safety and Emission Recall Campaign for certain 2015-2016 Mazda3 vehicles (built from May 21, 2015 through August 24, 2015), which could have a safety-related problem. A defect in the fuel shut-off valve may allow fuel to flow from the fuel tank into the charcoal emissions canister. With this condition, the check engine light may illuminate, and if the fuel exceeds the canister capacity, fuel leakage could occur, increasing the risk of a fire and/or engine stalling. Approximately 14,270 vehicles in the U.S. and 136 vehicles in Puerto Rico are affected. Owners of subject vehicles will be notified by mail in early October. They will be informed to bring their vehicle to the nearest Mazda dealer as soon as possible. Dealers will inspect the fuel tank to determine if the defect exists on the vehicle. If the defect exists, the dealer will replace the fuel tank and charcoal canister at no cost to the customer. A rental or loaner vehicle will be provided at no cost to the owner, until the vehicle is repaired for this concern. If there are no concerns, the vehicle will be returned to the customer. Should a customer not want to drive the vehicle to the dealership, they may contact Mazda's 24-hour Roadside Assistance service at 800-866-1998 and have the vehicle picked up and delivered to the dealership. There have been no reports of accidents or injury related to this issue.

Mazda refurbishing this NFL running back's 22-year-old daily driver

I don't actually care for the Washington Redskins (which is a good thing, considering the start to their season this year), but I love their running back, Alfred Morris. Why? Well, to start with, Morris helped deliver a dominating 10-3 season for my fantasy football team last year after a flash of prescience saw me pick him up off the waiver wire in Week 1 (hit me up on Twitter if you need fantasy sports insight, guys, I'm sort of like the Ruxin of Autoblog).
Morris is also pretty endearing because of his loyalty to his car, Bentley. Hold up - that's not to say the running back has splashed out on a Continental GT or a Flying Spur. No, Morris gave his much-loved 1991 Mazda 626 the tongue-in-cheek name "Bentley" while he was still a student at Florida Atlantic. One 1,613-rushing-yard rookie season and a $2.2-million contract later, and Morris is still using his Mazda as his daily driver. It might be easy to assume that the young player is simply being really prudent with all of his newfound wealth, but the guy really just has a thing for his five-speed-manual 626.
And Mazda, of course, loves the story of Morris' affection. In an effort to keep his 626 running strong and looking good, the company's Washington D.C.-area dealers have agreed to refurbish Bentley back to its original showroom freshness. Rather than spoil the classic (?) lines of the 626, the Mazda folks are essentially restoring the car for Morris. The cracked dash will be swapped out for a factory replacement, the engine and transmission given a thorough going-over and the whole vehicle generally made as fresh as Will Smith circa 1991. Bentley is expected to be completed and rolling through the capitol city by October 15, and in the meantime, Morris has been driving around in a new 2014 Mazda6 loaner car.