2022 Mazda Cx-5 2.5 S Carbon Edition Awd 4dr Suv on 2040-cars

Auto blog

Japan plans real-world diesel emissions test after companies fail

Japan's transport ministry plans to start real-world diesel emissions tests after an experiment found four models from Toyota, Nissan, and Mitsubishi that produced more nitrogen oxide (NOx) emissions than the nation's rules allow, according to The Japan Times. Regulators there usually only perform emissions checks in the lab. The VW diesel scandal has everyone double-checking their figures. Diesel versions of the Toyota Hiace van, Land Cruiser Prado, and Nissan X-Trail produced up to 10 times more NOx than allowed. The Mitsubishi Delica D:5 was up to five times over the limit, The Wall Street Journal reports. There was no evidence of defeat devices in the vehicles. Mazda performed well in the experiment, though. The CX-5 passed with nearly the same results on the road and in the lab. The Demio, better known as the Mazda2, did nearly as well with only slighter higher figures in the real world than in the controlled setting. The experimenters theorized the reason for the excessive emissions was that cold weather caused the engines' software to shut off the exhaust gas recirculation to prevent damage, according to the WSJ. However, this behavior also increased NOx production. Toyota, Nissan, and Mitsubishi don't have to worry about punishment from the transport ministry because this check was just an experiment. Their models already passed the mandated lab tests, which was the only requirement, according to The Japan Times. As governments begin greater real-world emissions tests, the results suggests diesels aren't very clean. A recent check in France found models from Ford, Renault, and Mercedes-Benz that didn't perform up to the standards. Regulators in India conducted similar evaluations and ordered VW to recall over 300,000 vehicles. Related Video:

Mazda goes on engineer hiring binge as recovery picks up speed

Japan's larger automakers - companies like Toyota, Honda and Nissan - have tremendous engineering talent at their disposal. That's largely because, selling as many cars as they do, they've got more revenues to tap into. Logic might dictate, then, that smaller automakers like Mazda, which no longer has the deep pockets afforded to it by its former partnership with Ford, might have less of a budget and workforce for engineering. But Mazda has been raking in record profits, and it plans on cashing those revenues in by hiring a substantial new pool of engineers.
According to Automotive News, Mazda is preparing to hire as many as 185 new engineers over the next two years - almost four times as many as the 50 engineers it previously targeted. Many of those engineers will be put to work developing the second-generation, Skyactiv 2 technologies that are on the drawing board while the first round of Skyactiv features are still being rolled out.
The boost in recruitment is enabled by a positive fiscal year that ended last March, marking the first profits Mazda had logged in four years. Sources anticipate that the fiscal year culminating at the end of this month will mark the company's most profitable yet, netting over a billion dollars to eclipse the fiscal year that ended in 2008 when it recorded $872.5 million in profits.

Takata airbag recall spreads to China with 42k Mazda sedans

The scope of the problem with the faulty airbag inflators from Takata continues to broaden and is now reaching China, as well. Mazda is recalling 42,732 Mazda6 units there, produced by its local joint venture partner China FAW Car Company, to replace the front passenger airbags. It comes as part of Mazda's recall of nearly 160,000 vehicles worldwide, including about 34,600 in the US, according to Reuters.
This is the same problem that caused seven automakers in the US to recall an estimated 2.1 million vehicles in late June. The airbag inflators can potentially explode instead of deploying the airbag, which hampers the bag's inflation. In some cases occupants are also hit by the metal shrapnel, which can cause further injuries. In the US, Mazda is repairing the 2003-2007 Mazda6 (pictured above), 2006-2007 Mazdaspeed6, 2004 MPV and 2004-2008 RX-8 originally sold in or currently registered in Florida, Puerto Rico, and Hawaii.
This is hardly the first instance of this issue. Since 2001, there have been 20 recalls tied to the exploding airbags supplied by Takata. The problem is possibly linked to the propellant in the inflators, but there's no conclusive evidence of that yet. Most of the automakers in the US limited the most recent recalls only to a few humid states because moisture potentially exacerbated the problem.