Sign Limited on 2040-cars

Auto blog

Ford recalls 1.48 million F-150s for transmission, plus other models

Weeks after recalling more than 800,000 F-Series pickup trucks for a fire risk, Ford has issued another separate recall for approximately 1.48 million 2011-2013 F-150s for a transmission fault. The six-speed automatics could unexpectedly downshift into first gear without warning. Ford and Lincoln tangentially issued much smaller recalls for the Mustang, Continental, Nautilus, and Navigator. According to Ford, some 2011-2013 model year F-150 pickups with six-speed automatic transmissions could "experience an intermittent loss of the transmission output speed sensor signal to the powertrain control module." This could potentially cause the trucks to temporarily downshift, which could be dangerous if it occurs while driving. Of the 1.48 million affected trucks, 1.26 million are in the U.S. while 221,000 are in Canada. Thus far, Ford knows of five reported accidents involving the issue. To remedy the problem, owners can take their trucks to dealers to update the power control module software. Ford also issued recalls for about 4,350 2019 Mustangs, Lincoln Nautiluses, and Lincoln Navigators in the U.S. and Canada due to a possible fault with the instrument clusters. Although there have been no reports of accidents, Ford says the instrument panel clusters assemblies might be blank or not turn out when the vehicle is started. Additionally, Ford issued a third recall for 28,200 2017-2019 Lincoln Continentals in the U.S. and Canada. Ford says silicon contamination might build up inside the door latch motor, causing it to malfunction. As a result, the door latch might not always fully engage, and the doors could possibly open unexpectedly. Despite no reports of accidents, Ford will remove and replace door latch assemblies on all doors for those affected by the defect. If any of these apply to a vehicle you own, contact Ford to discuss whether it is included in any of these recalls and have the vehicle checked out at a Ford dealership.

Ford recalls 83k Taurus and crossover models for halfshaft issue

Ford and the National Highway Traffic Safety Administration have issued a recall for some 83,250 vehicles in the US, for an issue with halfshafts. More specifically a "halfshaft retention circlip" might not have been properly installed on affected vehicles, with the result being halfshafts that may move improperly or disengage completely from the linkshaft while driving. The NHTSA release also notes that the issue may occur "without prior warning" which obviously factors in to the timeliness of getting this checked.
Should the halfshaft disengage, a few troubling things could happen. If it occurs while driving, power from the engine will no longer be transmitted to the wheels. And, if the vehicle is parked without the parking brake applied after disengagement of the circlip, vehicles may roll away even if they're transmissions have been placed in "Park."
Affected vehicles are as follows: Ford Edge and Lincoln MKX crossovers from model years 2012 to 2014; Ford Taurus and Lincoln MKS sedans from model years 2013 to 2014; Ford Flex and Lincoln MKT vehicles from model years 2013 to 2014.

Ford fixing 130k vehicles in three recalls

Ford is issuing three new safety campaigns that cover a total of 130,801 vehicles in North America, but the company has no reports of accidents, injuries, or fires from any of these issues. The largest of these campaigns covers 128,823 examples of the 2009-2010 Ford Edge and Lincoln MKX that are currently registered or originally sold in rust-prone areas of North America, including 110,636 in the US. On these crossovers, "corrosion under the reinforcement brackets where the fuel tank is mounted" can potentially result in a fuel leak. To fix the issue, dealers will inspect the tank and will repair or replace it as necessary. The affected locations are: Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin; and the Canadian provinces of New Brunswick, Newfoundland and Labrador, Nova Scotia, Ontario, Prince Edward Island, and Quebec. Ford is also recalling 1,906 North American examples of the 2016 Mustang, including 1,900 in the US, because of possible damage to some components during shipping to the factory. On the affected pony cars, "dealers will replace front and rear seat belt assemblies, rear seat buckle assemblies, and child tethers," the company says in its statement. Finally, the smallest campaign is for 72 units of the 2016 Ford E-Series cutaway and chassis cab in North America, including 65 in the US. On these, the trailer brakes don't activate when pressing the brake pedal, and dealers need to update the powertrain control module software. Related Video: FORD ISSUES TWO SAFETY RECALLS AND ONE SAFETY COMPLIANCE RECALL IN NORTH AMERICA DEARBORN, Mich., Oct. 28, 2015 – Ford Motor Company is issuing two safety recalls and one safety compliance recall in North America. Ford is not aware of any accidents, injuries or fires related to these conditions. Details are as follows: Ford Motor Company issues safety recall for certain 2009-2010 Ford Edge and Lincoln MKX vehicles in North America for potential fuel tank issue Ford Motor Company is issuing a safety recall for approximately 129,000 2009-2010 Ford Edge and Lincoln MKX vehicles in corrosion states and provinces in North America for possible corrosion under the reinforcement brackets where the fuel tank is mounted to the vehicle.