1989 Lincoln Mark Vii Lsc Sedan 2-door 5.0l on 2040-cars

Auto blog

Ford issues six recalls covering 101,000 vehicles for multiple issues

Ford is announcing six separate recalls for a variety of issues affecting a dozen models and a total of 100,610 vehicles in North America. However, according to Ford spokesperson Kelli Felker, "None of them have caused accidents or injuries." Half of them cover fewer than 1,000 cars.
The largest recall covers 92,022 North American examples (about 83,250 in the US) of some models of the Ford Taurus, Lincoln MKS, Ford Interceptor, Flex and Lincoln MKT from the 2013 and 2014 model years; the 2012-2014 Edge and the 2014 Lincoln MKX. All of them have a potential issue with the halfshaft on the right side that might not be fully seated and could move outward over time. If it shifts too far, the models may no longer be able to drive, and the condition could also allow the vehicles to roll away, even when in Park. Dealers will inspect the shaft to make sure it's seated and will replace the part if necessary.
The next-largest recall covers 5,264 North American examples (4,867 in the US) of the Ford F59 Commercial Stripped Chassis from the 2011-2014 model years. It's possible that an electrical junction box can corrode in areas with salty roads and short circuit. The problem could potentially cause a fire. Dealers will replace the box with an improved design.

NHTSA upgrades Ford floor mat unintended acceleration probe

According to a Bloomberg report, the National Highway Traffic Safety Administration has upgraded an investigation into complaints of unintended acceleration lodged against Ford vehicles. The investigation began in June of 2010 when just three complaints had been received and it only concerned the Ford Fusion and Mercury Milan, but this was at a time when the phrase "unintended acceleration" made grown men go pale. With 49 additional complaints received since then, the investigation has been reclassified as an engineering analysis - the last phase before a recall - and it has been expanded to include the Lincoln MKZ, making for a total of "around 480,000" units affected between the three sedans from the 2008 to 2010 model years.
The ostensible cause is that floor mats are trapping the accelerator pedal, but according to a Ford statement at the time, the entrapment is due to owners placing the optional all-weather floor mats, or aftermarket floor mats, on top of the car's standard floor mats. NHTSA has backed up that assessment, pinning the blame on "unsecured or double stacked floor mats."
On the face of it, it would appear that NHTSA has upgraded the status not because of Ford's error, but owner error, and Ford has stated publicly that it is "disappointed" in NHTSA's move. On top of NHTSA still being skittish after that other unintended acceleration debacle, it could be seen to be taking its time investigating all of the variables: it's reported that Ford changed its accelerator pedal design in 2010, a "heel blocker" in the floorpan has been considered a potential culprit in how the floor mats could be trapping the pedal, some drivers have said the floor mats weren't anywhere near the pedal, and according to a report in the LA Times, in "a letter sent by Ford to NHTSA in August 2010, the automaker said it found three injuries and one fatality that 'may have resulted from the alleged defect.'"

Ford Explorer problems gutted third-quarter sales

In early September, the Detroit Free Press published a feature noting numerous problems Ford's having with the 2020 Explorer and 2020 Lincoln Aviator launches. Issues with both SUVs, built at Ford's Chicago Assembly Plant, were so rife and dire that the automaker was trucking the vehicles 275 miles away to Michigan for repairs. Bloomberg reported earlier this month that Explorer's third-quarter sales dropped 48 percent compared to the previous model in 2018, with dealers unable to get enough units on lots for customers. Nor is the snafu over: Automotive News reports that another "batch of about 2,500 Explorers in need of repairs" arrived recently in Michigan, and sales through the first nine months of 2019 are down 31 percent. Sales dips during model changeovers are to be expected as old inventory gets sold down and new production ramps up, but this is different. Ford U.S. sales boss Mark LaNeve told Bloomberg earlier this month, "We’ve got adequate inventory in our stores. For Q4, availability wonÂ’t be an issue. WeÂ’ll be able to hit our stride with Explorer starting now." It's hard to know whether that's true, with thousands of Explorers still piling into Michigan; the batch AN mentioned represents about 5 days of sales during an average month in 2018, before the drawdown and interruptions hampered matters. And when Consumer Reports tested the Ford Explorer it bought this summer, it titled the review, "2020 Ford Explorer drives nicely but has many flaws / Poor interior quality and a high price overshadow the SUV's improvements."   On top of that, the AN piece mentions a new impediment to uncorking the Explorer sales stream: Worker strife in the Chicago plant. Allegedly, "Roving groups of workers are intimidating other employees, creating a hostile environment, the people said. ThatÂ’s driving up turnover and leaving some vehicle assembly unfinished, contributing to the company having to complete the work at the Michigan factory or at dealerships, the people said." Ford's been fined twice before for the same kinds of issues at its plants, once in 1999, again in 2017, but a spokesperson said Ford isn't aware of any such problems now. The pressure otherwise has got to be unpleasant for everyone on the Explorer team, from CEO Jim Hackett down. The automaker was meant to be "turning the corner" in April, but as of now, shares are down, credit rating is down, earnings are down.