2011 Lincoln Mks Navigation Rearcam Ultimate Pkg Dual Roof Heated Ac Seats 40k on 2040-cars

Auto blog

Ford recalls more than 550,000 trucks and SUVs for various safety issues

Ford announced safety recalls for its current F-150 pickup along with several Ford and Lincoln crossovers early Wednesday. The recalls cover more than 550,000 vehicles and address various safety defects, ranging from a fire hazard to potential loss of braking power.  The most far-reaching of the recalls covers approximately 550,000 examples of the 2015-2018 Ford Edge and 2016-2018 Lincoln MKX, which may have been assembled with defective front brake jounce hoses (also commonly referred to as "flex lines"). These hoses run from fixed points on the chassis to the individual front brake calipers. Defective hoses could potentially rupture, allowing brake fluid to leak and resulting in a loss of braking function. Ford will replace the components in question with revised parts.  The next-largest recall is for roughly 3,000 2020 Lincoln Corsair crossovers. The affected models may have been assembled without proper clearance between their rear suspension springs and toe link brackets. The components could potentially make contact, wearing down the protective coating on the rear coil springs, allowing corrosion to occur over time. This corrosion could eventually lead to a failure of the spring. If this happens while the vehicle is being driven, it could result in a sudden change to the vehicle's handling characteristics, and the spring fragments could potentially cause further damage to the car or surrounding traffic.  Ford says owners will be notified that their Corsairs need to be inspected; if there is not adequate clearance between the rear suspension components, Ford's service technicians will remove material from the toe link bracket to allow for operation without contact.  The final (and by far the smallest) recall is for the 2020 F-150. Some units may have left the factory with the incorrect retention nut on the hot lead to the starter motor. Ford says it can cause increased heat generation or electrical arcing, which could potentially result in a fire. Ford says this issue is limited to just a few hundred examples sold in the United States. Dealers will inspect the vehicles and replace the nut if necessary.       

Ford will keep Escape and MKC plant open an extra week to meet demand

Crossovers keep selling like popular pastries, and for Ford, that means it needs to keep production going. The company announced that, rather than the usual two-week shutdown, its Louisville, Ky., assembly plant will be open for one of those weeks. The plant builds the Ford Escape and Lincoln MKC, which Ford reports have had record sales. According to Ford, Escape sales through May are up 3 percent, and MKC sales are up 10 percent compared with last year. In total, the Escape has sold about 130,000 units through May, and the MKC has sold around 11,000. Keeping the Louisville plant open will allow the company to build an additional 8,500 vehicles. Ford stated that all other assembly plants will continue with the two-week shutdown as scheduled. Related Video: Featured Gallery 2017 Ford Escape: First Drive View 24 Photos Image Credit: Drew Phillips Plants/Manufacturing Ford Lincoln Crossover SUV Economy Cars Luxury lincoln mkc

Ford Explorer problems gutted third-quarter sales

In early September, the Detroit Free Press published a feature noting numerous problems Ford's having with the 2020 Explorer and 2020 Lincoln Aviator launches. Issues with both SUVs, built at Ford's Chicago Assembly Plant, were so rife and dire that the automaker was trucking the vehicles 275 miles away to Michigan for repairs. Bloomberg reported earlier this month that Explorer's third-quarter sales dropped 48 percent compared to the previous model in 2018, with dealers unable to get enough units on lots for customers. Nor is the snafu over: Automotive News reports that another "batch of about 2,500 Explorers in need of repairs" arrived recently in Michigan, and sales through the first nine months of 2019 are down 31 percent. Sales dips during model changeovers are to be expected as old inventory gets sold down and new production ramps up, but this is different. Ford U.S. sales boss Mark LaNeve told Bloomberg earlier this month, "We’ve got adequate inventory in our stores. For Q4, availability wonÂ’t be an issue. WeÂ’ll be able to hit our stride with Explorer starting now." It's hard to know whether that's true, with thousands of Explorers still piling into Michigan; the batch AN mentioned represents about 5 days of sales during an average month in 2018, before the drawdown and interruptions hampered matters. And when Consumer Reports tested the Ford Explorer it bought this summer, it titled the review, "2020 Ford Explorer drives nicely but has many flaws / Poor interior quality and a high price overshadow the SUV's improvements."   On top of that, the AN piece mentions a new impediment to uncorking the Explorer sales stream: Worker strife in the Chicago plant. Allegedly, "Roving groups of workers are intimidating other employees, creating a hostile environment, the people said. ThatÂ’s driving up turnover and leaving some vehicle assembly unfinished, contributing to the company having to complete the work at the Michigan factory or at dealerships, the people said." Ford's been fined twice before for the same kinds of issues at its plants, once in 1999, again in 2017, but a spokesperson said Ford isn't aware of any such problems now. The pressure otherwise has got to be unpleasant for everyone on the Explorer team, from CEO Jim Hackett down. The automaker was meant to be "turning the corner" in April, but as of now, shares are down, credit rating is down, earnings are down.