2004 Lincoln Ls Base Sedan 4-door 3.9l on 2040-cars

Auto blog

Ford issues six recalls covering 101,000 vehicles for multiple issues

Ford is announcing six separate recalls for a variety of issues affecting a dozen models and a total of 100,610 vehicles in North America. However, according to Ford spokesperson Kelli Felker, "None of them have caused accidents or injuries." Half of them cover fewer than 1,000 cars.
The largest recall covers 92,022 North American examples (about 83,250 in the US) of some models of the Ford Taurus, Lincoln MKS, Ford Interceptor, Flex and Lincoln MKT from the 2013 and 2014 model years; the 2012-2014 Edge and the 2014 Lincoln MKX. All of them have a potential issue with the halfshaft on the right side that might not be fully seated and could move outward over time. If it shifts too far, the models may no longer be able to drive, and the condition could also allow the vehicles to roll away, even when in Park. Dealers will inspect the shaft to make sure it's seated and will replace the part if necessary.
The next-largest recall covers 5,264 North American examples (4,867 in the US) of the Ford F59 Commercial Stripped Chassis from the 2011-2014 model years. It's possible that an electrical junction box can corrode in areas with salty roads and short circuit. The problem could potentially cause a fire. Dealers will replace the box with an improved design.

Ford announces four recalls, 1.4M vehicles affected

Ford is taking a bit of the spotlight away from General Motors, announcing a major group of recall campaigns, covering a total of 1.4 million vehicles built between 2006 and 2013.
Let's start with the big one, which covers the Ford Escape, Mercury Mariner and, according to The Detroit News, Ford-built Mazda Tribute CUVs. 915,216 vehicles are covered, all of which were built in model years 2008 to 2011. 736,000 vehicles are in the US, while Canada then Mexico make up the vast majority of the remainder. The problem is due to an issue with the torque sensor in the steering column, which could lead to sudden power steering failure. Manual steering would still be available, though.
"Dealers will perform one of three service fixes, depending upon what diagnostic codes are shown when the vehicle is taken to the dealer," Ford spokeswoman Kelli Felker wrote to Autoblog in an email. "They will either update software for the power steering control module and the instrument cluster module; replace the torque sensor; or replace the steering column, which includes upgraded power steering control module software."

Lincoln prepping MKZ re-launch?

Launching an all-new car is no easy task. Case in point is the 2013 Lincoln MKZ, introduced with the fanfare of a major nationwide marketing campaign, including expensive Super Bowl ads, just as Ford was curbing production over potential quality issues. The resulting mess was nothing short of a nightmare for any automaker - customers visiting dealerships looking for cars that hadn't been delivered yet. Disappointed buyers walked out of Lincoln retailers without new keys in their hands, or switched to a competing brand to fill empty spaces in their driveways.
The impact was painful, as Lincoln's sales in January and February of this year were among the lowest it has recorded in more than a quarter century. Even though March looked a bit brighter, with the supply crisis reportedly over (there are 3,000 units in transit and production is approaching 200 units per day) the automaker is reportedly studying the feasibility of giving its pivotal MKZ the launch it originally deserved.
According to TheDetroitBureau.com, putting the MKZ back on consumer's radar could cost Ford tens of millions of dollars, but that kind of investment may be warranted if potential buyers have forgotten about the new model... or worse, if they have forgotten about Lincoln.