2009 Lexus Is250 Awd Fully Loaded 80+ Photos See Description Must See Wow!!! on 2040-cars

Auto blog

Toyota and Lexus recalling 235,000 hybrid CUVs and sedans over separate issues

When it rains, it pours. Toyota has announced a pair of separate but voluntary North America recalls covering approximately 235,000 vehicles built between 2006 and 2011. The larger of the two recalls targets Toyota's hybridized crossovers, the Lexus RX400h and Toyota Highlander Hybrid. 133,000 units, including 2006-2010 Highlander and 2006-2008 RX crossovers are covered in the campaign. The other recall affects 102,000 IS350 sedans, IS350C convertibles and GS350 sedans built between 2006 and 2011.
With the CUVs, the faults in the parallel circuits of the transistors can cause heat damage in the inverter assembly, triggering an abundance of warning lamps and sending the vehicle into limp mode. The Lexus sedans are being recalled due to loose bolts on the variable valve timing controller. Detected by unusual underhood sounds on startup, the issue can cause the engine to stop while driving. The inverter issue is also triggering similar recalls in Japan and Europe.
At the moment, it's unclear if any of these issues have caused any crashes or injuries. Toyota says it plans to notify owners of the recall via snail mail. Additional information for owners can be found on the recall sites for Toyota and Lexus or by calling Toyota's customer service line, at 1-800-331-4331. Scroll down for the complete recall notice from Toyota.

Toyota recalls 337,000 RAV4s and HS250h models for tie rod failure

UPDATE: The post has been updated with additional information from NHTSA. The Basics: Toyota is recalling 337,000 2006-2011 model year Toyota RAV4 crossovers built between October 31, 2005 and September 7, 2010 as well as 2010 model year Lexus HS250h cars built between July 6, 2009 and August 26, 2010. The Problem: When either an affected RAV4 or HS250h is given an alignment and the tie rod adjustment nut on the rear control arm isn't tightened properly, the threads on the tie rod can start to rust. If this happens, the nut may break off and throw off the alignment drastically and suddenly. This isn't a case of the car simply pulling to one side, either. This would seriously upset the balance of the car and could cause the driver to lose control and crash. This is also the third time these vehicles have been recalled for the same issue. Injuries/Deaths: It's unknown if this control arm issue has resulted in any injuries or deaths. Autoblog reached out to Toyota for more information, but a company representative told us that the company isn't able to discuss injuries or deaths caused by this issue (if any) at this time. Based on information from NHTSA documents, it does not appear that any crashes, injuries or deaths have been attributed to the defect addressed in the current recall. The Fix: The dealer will completely replace the rear suspension assemblies at no cost to the owner. The tie rods and nuts will also be coated in epoxy to prevent future rusting from occurring. According to Car and Driver, the previous recalls involved tightening nuts, coating decent tie rods in epoxy and completely replacing rusted ones. The car magazine reports that further complaints were filed and the company is now replacing all components regardless of condition. If you own one: Toyota will notify owners of affected cars by mail. Owners can also check whether their cars are affected by entering the VIN at safercar.gov/vin. Owners with questions can also reach Toyota customer service at 1-800-331-4331 or Lexus customer service at 1-800-255-3987. Related Video: Featured Gallery 2012 Toyota RAV4 View 16 Photos News Source: Car and Driver, Toyota, National Highway Traffic Safety AdministrationImage Credit: Toyota Recalls Lexus Toyota Safety lexus hs 250h lexus hs250h

Lexus eschews production in China over quality concerns

One of the more popular trends in the auto industry is setting up production operations in China. Mainstream manufacturers like Ford, General Motors and Volkswagen have done it, and even luxury marques like Audi, BMW and Mercedes-Benz have or will soon have manufacturing ops in the People's Republic.
One company that isn't building cars in China, though, is Lexus. The Toyota-owned luxury brand still manufactures all of its vehicles in Japan (aside from a few RXs, which are built at a Toyota factory in Canada). According to Tokuo Fukuichi, Lexus just isn't ready to build cars there yet.
"The German Three have a brand image that they have cultivated over the past century in their long history, but Lexus is not in people's minds like that yet," Fukuichi-san told Reuters UK.