All Black 2010 Jeep Wrangler Unlimited Rubicon -38,000 Miles on 2040-cars

Auto blog

Chrysler taking big risk snubbing NHTSA

Maker Insists Feds Overstate Risk Of Fires With Grand Cherokee, Liberty Models
It's not often that recall stories make it above the fold, in that old newspaper parlance, but when one shows up as the lead story on the network evening news programs, you know it's something big.
And so it is with Chrysler snubbing its nose at a request by the National Highway Traffic Safety Administration to recall 2.7 million Jeeps the feds insist are at risk of potentially catastrophic fuel tank fires in a rear-end collision.

Government Ending Jeep Investigation

The government is closing its investigation into older-model Jeeps with fuel tanks that could rupture and cause fires. The National Highway Traffic Safety Administration said Friday it has "no reservations" with Chrysler Group's plans to recall the vehicles. The agency is expected to release a report on its investigation in a few weeks. The decision ends an unusually public struggle between Chrysler and NHTSA. The agency asked Chrysler to recall 2.7 million Jeeps last June, contending that their gas tanks - which are positioned behind the rear axle - were at risk of rupturing and catching fire in rear-end crashes. Involved were Grand Cherokee SUVs from the 1993 to 2004 model years and Liberty SUVs from 2002 to 2007. Chrysler initially refused to recall the vehicles. The company said the rate of fuel leaks and fires after crashes was similar to comparable vehicles that were sold during the time in question. It was the first time in two years that an automaker had refused NHTSA's request for a recall. Chrysler later agreed to recall 1.56 million of the Jeeps and install trailer hitches on them to help protect the gas tanks. The company sent notices to the remaining customers saying their vehicles were fine if they have factory-installed or Chrysler-made trailer hitches. NHTSA said late Friday that it has been in close contact with Chrysler and will monitor the recall as it continues. Chrysler has told customers that it will start installing the hitches soon. "Consumers should have their vehicles serviced promptly once they receive final notification from Chrysler,"NHTSA said in a statement. In its own statement Friday, Chrysler said, "We share NHTSA's commitment to safety." NHTSA's outgoing chief, David Strickland, told The Associated Press in an interview last month that Chrysler had convinced NHTSA that the Jeeps were no more dangerous than similar vehicles sold at that time. "Those vehicles performed at a rate similar to their peers. That is the keystone analysis as to whether something poses an unreasonable risk to safety," Strickland said. Friday was Strickland's last day at NHTSA. He is joining Venable, a law firm. NHTSA began investigating the Jeeps at the request of the Center for Auto Safety, a Washington-based advocacy group. "It is tragic that NHTSA approved Chrysler's sham trailer hitch recall for Jeeps that explode in rear impacts," the Center for Auto Safety's director, Clarence Ditlow, said Friday.

Dodge and Jeep recalling 895k SUVs for possibility of headliner fires

Dodge and Jeep are announcing recalls of a total of 895,000 Durango and Grand Cherokee models worldwide from the 2011 through 2014 model years. There's a possibility that the wiring in the sun visor can short circuit and cause a fire. It specifically affects vehicles built between January 5, 2010, and December 11, 2013, and there are approximately 651,000 of them in the US, 45,700 in Canada, 23,000 in Mexico and 175,000 outside of North America.
Screws that fasten the sunvisor to the headliner may pierce wires in the visor, if the part has been removed or serviced, potentially causing a fire risk. If the wires short circuit, they could overheat and potentially combust. The automakers report three injuries caused by this defect, and according to the investigation by the National Highway Traffic Safety Administration, "there may be a total of 52 unique fire incidents."
To fix the problem, Dodge and Jeep will inspect the vehicles for suspect wiring, and all of the models, whether damaged or not, will get a new sun visor spacer with a wire guide to stop the possibility of short circuits. According to the automakers' announcement, "this condition is not present in vehicles which have not had the headliner or vanity mirror serviced." They will notify affected owners, and repairs will begin in August.