2012 Jeep Wrangler Sport Sport Utility 2-door 3.6l on 2040-cars

Auto blog

Jeep Liberty under investigation for door fires

The Jeep Liberty has already had plenty of attention for possible fires thanks to the first-gen model's fuel tank, but now the midsize Jeep is under the microscope of the National Highway Traffic Safety Administration for another fire-related concern. NHTSA has opened an investigation for the 2012 Liberty after receiving two reports of electrical fires in the driver's door.
According to the investigation summary, around 80,000 vehicles could potentially be affected by this problem. In both reported fires, the drivers noticed smoke and then flames from the master power window switch, and they had to pull to a stop and exit through the passenger side of the SUV. According to Autoguide, there was one injury to a motorist who suffered burned fingers while trying to open the driver's door.
Interestingly, the Dodge Nitro is not yet involved in this investigation, even though it was still around for the 2012 model year; the Nitro ended production in 2011 about a year before the final Liberty rolled off the line for the 2013 model year. Scroll down for the official NHTSA investigation summary.

Government Ending Jeep Investigation

The government is closing its investigation into older-model Jeeps with fuel tanks that could rupture and cause fires. The National Highway Traffic Safety Administration said Friday it has "no reservations" with Chrysler Group's plans to recall the vehicles. The agency is expected to release a report on its investigation in a few weeks. The decision ends an unusually public struggle between Chrysler and NHTSA. The agency asked Chrysler to recall 2.7 million Jeeps last June, contending that their gas tanks - which are positioned behind the rear axle - were at risk of rupturing and catching fire in rear-end crashes. Involved were Grand Cherokee SUVs from the 1993 to 2004 model years and Liberty SUVs from 2002 to 2007. Chrysler initially refused to recall the vehicles. The company said the rate of fuel leaks and fires after crashes was similar to comparable vehicles that were sold during the time in question. It was the first time in two years that an automaker had refused NHTSA's request for a recall. Chrysler later agreed to recall 1.56 million of the Jeeps and install trailer hitches on them to help protect the gas tanks. The company sent notices to the remaining customers saying their vehicles were fine if they have factory-installed or Chrysler-made trailer hitches. NHTSA said late Friday that it has been in close contact with Chrysler and will monitor the recall as it continues. Chrysler has told customers that it will start installing the hitches soon. "Consumers should have their vehicles serviced promptly once they receive final notification from Chrysler,"NHTSA said in a statement. In its own statement Friday, Chrysler said, "We share NHTSA's commitment to safety." NHTSA's outgoing chief, David Strickland, told The Associated Press in an interview last month that Chrysler had convinced NHTSA that the Jeeps were no more dangerous than similar vehicles sold at that time. "Those vehicles performed at a rate similar to their peers. That is the keystone analysis as to whether something poses an unreasonable risk to safety," Strickland said. Friday was Strickland's last day at NHTSA. He is joining Venable, a law firm. NHTSA began investigating the Jeeps at the request of the Center for Auto Safety, a Washington-based advocacy group. "It is tragic that NHTSA approved Chrysler's sham trailer hitch recall for Jeeps that explode in rear impacts," the Center for Auto Safety's director, Clarence Ditlow, said Friday.

Chrysler says its 8-speed transmissions will save 700 million gallons

Chrysler Group's TorqueFlite eight-speed transmission could be earning some serious green bragging rights if the company's projections are correct. The recently widely proliferated automatic gearbox, which is now in more than a million vehicles around the world, is poised to save drivers an estimated 700+ million gallons of fuel over the vehicles' lifetimes (an expected cost savings of $2.5 billion). In addition, Chrysler expects a reduction in CO2 emissions by more than six million metric tons. According to Chrysler, and depending on the vehicle, the TorqueFlite can improve fuel economy. The TorqueFlite autobox features particularly close ratios from fifth to eighth gear (see the press release below for the specific numbers), and uses low-viscosity fluid that doesn't need to be replaced. Transmission software adapts to the driving situation to optimize efficiency based on driver behavior, temperature, grade, stability control, and longitudinal and lateral acceleration. The TorqueFlite is capable of handling a variety of duties. As evidenced by the wide range of vehicles Chrysler Group has seen fit to equip with the eight-speed transmission, the TorqueFlite is capable of handling a variety of duties. Since its 2012 introduction, the TorqueFlite has gone from performing cog-swapping duties in Dodge Charger and Chrysler 300 models equipped with the 3.6-liter Pentastar V6 to changing gears in vehicles such as the Pentastar- and Hemi-powered Dodge Durango, Jeep Grand Cherokee and even the Ram 1500 EcoDiesel. For the 2015 model year, the eight-speed is finding its way into even more vehicles with the addition of a third version. In addition to the American-made TorqueFlite 845RE and 8HP70, the new 8HP90 will be manufactured in Saarbrucken, Germany. The 8HP90 is designed for higher torque loads, making it ideal for high-performance vehicles like the 2015 Dodge Challenger SRT Hellcat. The already-in-use 8HP70 will expand its duties to be used in 2015 Hemi models such as the Dodge Charger, Challenger, and Challenger SRT8. You can see the list of those benchmarks in Chrysler's press release below.