2004 Jeep Wrangler X Sport Utility 2-door 4.0l on 2040-cars

Auto blog

NHTSA investigating 2015 Jeep Cherokee after new owner's total-loss fire [w/video]

The National Highway Traffic Safety Administration has opened a Preliminary Evaluation into the 2015 model year Jeep Cherokee after a single example caught on fire in California. This investigation will decide the cause, scope and frequency of this possible problem and will decide whether a recall is necessary for 50,415 potentially affected examples. According to Automotive News, the Cherokee's owner only purchased the CUV about two days before the fire, and it had been driven less than 100 miles. The new buyer reported parking the Jeep, and noticed a smell like smoke. Shortly after, the vehicle was consumed in flames. There were no injuries, but much of the incident was captured on video. NHTSA is also trying to decide whether another report is related. In this case, a driver noticed smoke under the hood of a 2015 Cherokee with just 45 miles on it, while driving at 60 miles per hour. According to the complaint to the agency, "the vehicle was not diagnosed or repaired," but FCA was notified. Read below NHTSA's announcement of the Preliminary Evaluation. CBS News 8 - San Diego, CA News Station - KFMB Channel 8 INVESTIGATION Subject : Engine compartment fire Date Investigation Opened: JAN 13, 2015 Date Investigation Closed: Open NHTSA Action Number: PE15003 Component(s): ENGINE Vehicle Make Model Model Year(s) JEEP CHEROKEE 2015 Manufacturer: Chrysler (FCA US LLC) SUMMARY: The Office of Defects Investigation (ODI) has received one complaint (VOQ) of engine compartment fire in model year (MY) 2015 Jeep Cherokee vehicles alleging a severe engine compartment fire incident resulting in a total vehicle loss (VOQ # 10672201). The consumer alleges that the entire vehicle was engulfed in flames approximately 20 feet high within seconds of parking the vehicle. The complaint alleged white smoke coming from under the hood immediately after parking the vehicle and while the ignition is off. In addition, ODI has identified field report data submitted as part of Early Warning Reporting that relate to the alleged defect. A Preliminary Evaluation has been opened to assess the cause, scope and frequency of the alleged defect. The following VOQ numbers are associated with the issues discussed in this opening resume: 10670034, 10672201.

FCA goes all-in on Jeep and Ram brands on cheap gas bet

It's no surprise that as SUV and truck sales remain strong in the wake of unusually cheap gas, Jeep and Ram sales are taking off. What is a surprise is that FCA CEO Sergio Marchionne thinks that cheap gas will be a "permanent condition," and feels strongly enough about it to change up North American manufacturing plans. Jeep appears to be the biggest beneficiary of the product realignment. In addition to increasing the sales estimates for the brand worldwide upwards to 2 million units a year by 2018, the brand will get a flood of investment for new product and powertrains. Consider the Wrangler Pickup to be part of the salvo, as well as the Grand Wagoneer three-row announced in 2014 as part of the original five-year plan. The Wrangler four-door will get at least two new powertrains, a diesel and mild hybrid version, in its next generation. That mild hybrid powertrain may utilize a 48-volt electrical system like the one that's being developed by Delphi and Bosch – which the suppliers think will be worth a 10 to 15 percent fuel economy gain at a minimum. Down the road, in the 2020s, the Wrangler could adopt a full hybrid system. The diesel powertrain is planned for 2019 or 2020. The Ram 1500 is also pegged to receive a mild hybrid system, again potentially based on 48-volt architecture, sometime after 2020. Lastly, Jeep and Ram will take over some of the production capacity of existing plants. The Sterling Heights, MI, plant that builds the Chrysler 200 will now build the Ram 1500; the Belvidere, IL, facility that produces the Dodge Dart will take over Cherokee output; the big Jeep facility in Toledo, OH, will be used for increased Wrangler demand. In 2015, according to FCA's numbers, car and van demand went down by 10 percent, but SUV demand went up 8 percent and truck demand 2 percent. Considering that these are high-margin vehicles, FCA can't ignore the math. FCA also won't build any new factories to supplement production to meet demand, but instead are reshuffling production priorities. Think of it this way: FCA is gambling on cheap gas being a permanent part of our lives, at least into the 2020s. By doubling down on SUVs and trucks, the company stands to win big, unless a spike in gas prices changes the landscape. FCA isn't talking about a Plan B, so they're all in. It'll be interesting to see how this plays out.

Dodge and Jeep recalling 895k SUVs for possibility of headliner fires

Dodge and Jeep are announcing recalls of a total of 895,000 Durango and Grand Cherokee models worldwide from the 2011 through 2014 model years. There's a possibility that the wiring in the sun visor can short circuit and cause a fire. It specifically affects vehicles built between January 5, 2010, and December 11, 2013, and there are approximately 651,000 of them in the US, 45,700 in Canada, 23,000 in Mexico and 175,000 outside of North America.
Screws that fasten the sunvisor to the headliner may pierce wires in the visor, if the part has been removed or serviced, potentially causing a fire risk. If the wires short circuit, they could overheat and potentially combust. The automakers report three injuries caused by this defect, and according to the investigation by the National Highway Traffic Safety Administration, "there may be a total of 52 unique fire incidents."
To fix the problem, Dodge and Jeep will inspect the vehicles for suspect wiring, and all of the models, whether damaged or not, will get a new sun visor spacer with a wire guide to stop the possibility of short circuits. According to the automakers' announcement, "this condition is not present in vehicles which have not had the headliner or vanity mirror serviced." They will notify affected owners, and repairs will begin in August.