2021 Jeep Other on 2040-cars

Auto blog

7 months later, Jeep 'trailer hitch' recall still stalled

For the past few years, Chrysler and its CEO, Sergio Marchionne, have gone head-to-head with the National Highway Traffic Safety Administration and its boss, David Strickland, over the government safety agency's request for Chrysler to recall almost three-million Jeep vehicles due to what NHTSA says is a safety issue that has caused at least 51 deaths. After a three-year investigation and Chrysler's initial refusal to issue a recall because it deemed the vehicles safe and built to the day's federal requirements, last summer, the two parties compromised on a "voluntary campaign" to inspect 1.56 million vehicles, those being the 1992 to 1998 Grand Cherokee and 2002 to 2007 Liberty.
Those vehicles were designed with their gas tanks between the rear axle and the bumper, and NHTSA says that in rear-end collisions, damage to the fuel tank has caused fires responsible for those 51 deaths. The compromise reached last summer was that Chrysler would inspect 1.56 million vehicles and, "if necessary, provide an upgrade to the rear structure of the vehicle." Practically speaking, that meant Chrysler would replace aftermarket trailer hitches, but would take no action if a vehicle had a factory-installed hitch or an aftermarket hitch from Mopar.
A report in The Detroit News says the "voluntary campaign" is just now getting under way, with Chrysler saying last week that the design of the replacement part had been finalized and it was tooling up "to deliver the required volume." Seven months later, still in question is whether NHTSA will crash-test the fix engineered by Chrysler, noteworthy because not only did the vehicles in question pass every safety standard necessary to be cleared for sale at the time, there are still questions (to those of us on the outside) as to how the Jeeps at issue fare among their peers in such incidents. Either way, Chrysler and NHTSA apparently still disagree on the efficacy of the remedy itself: the carmaker says it might help in low-speed crashes but not high-speed collisions, a position the NHTSA is at odds with. All of this means the campaign doesn't yet have an end in sight.

Are future vehicular hacks inevitable?

Before the hack of the Uconnect system in a Jeep Cherokee resulted in a 1.4-million vehicle recall, the potential software vulnerabilities in vehicles were already a hot topic with Congressional inquiries and even proposed legislation in the US. As cars' interconnected systems gain the ability to go online, they become open to a host of new threats. Automakers are trying to stop this, but it might be too late to put the genie back into the bottle. Throughout 2015, the issue of software security in vehicles has become increasingly vital. For example, the recent Jeep case wasn't even the biggest hack this year. In February, a major flaw was discovered in the BMW Connected Drive service that allowed researchers to remotely lock and unlock the doors and potentially affected 2.2 million cars. The fix was an over-the-air patch for the problem. Automakers are actively working to fix the issues. Mercedes-Benz, BMW, and Audi reportedly are using encrypted connections and firewalls in their vehicles to prevent hacking. "Absolute, 100-percent safety isn't possible," Daimler spokesperson Benjamin Oberkersch said to Automotive News Europe. "But we develop our systems, tested by internal and external experts, so they're up to date." These vulnerabilities seem to be popping up more often. A successful hack took $14 in parts from Radio Shack in one case. There was also a 60 Minutes report earlier in the year about DARPA's ability to hack into OnStar to take control of a Chevrolet Impala. Experts aren't so sure companies can contend with hackers' advancement. "The difficulty for the carmakers at the moment is the question whether they can keep pace with advances in technology, and especially hacking technology," Rainer Scholz, executive director for telematics consultant EY, said to Automotive News Europe. "We seriously doubt they can." At this point, vehicle hacks are coming more from researchers looking for holes than from those with malicious intent. Still, the vulnerabilities are definitely there. It's up to automakers to keep patching the problems before they become dangerous to drivers. Related Video: News Source: Automotive News Europe - sub. req.Image Credit: Bill O'Leary / The Washington Post via Getty Images Audi BMW Jeep Mercedes-Benz Safety Technology Emerging Technologies hacking cyber security

What's really going on with the 2014 Jeep Cherokee's transmission issues?

On September 23, Automotive News reported that Chrysler had idled the second shift workers it hired just five weeks prior at its Toledo Assembly Complex to build the 2014 Jeep Cherokee. At the time, Chrysler said it had "built the critical number of vehicles we need to stock dealerships once containment is released" and did not want "to put additional strain on our logistics partners ... upon release." That reasoning was not only unusual, it didn't seem to make sense.
It appears the center of the nine-speed issue is software, not hardware.
That same day, the Detroit News ran a piece claiming workers at the Toledo factory said the halt was due to issues with the Cherokee's transmission. It put the number of already-built Cherokees needing fixes at 1,000 and said that some of the workers not laid off had been instructed "to take the Jeep on long test-drives." That made more sense. Three days later, on September 26, Automotive News reported that the 500 workers laid off had been reinstated, with engineers "speeding repairs on the SUV's powertrain software." The AN piece didn't put a number on how many units are being fixed, but it did say that 12,000 have been built and are awaiting delivery to dealers. The best it could say about when dealers will get them, however, is that "progress on a fix is being made. It's unclear when shipments to dealers will start."