2020 Jeep Grand Cherokee Limited 4x4 on 2040-cars

Auto blog

Fires, deaths continue after Jeep fuel tank recall

As Kayla White slowed her SUV behind two other cars to exit a suburban Detroit freeway on Veterans Day, it was rammed from behind by a Cadillac STS. Her red 2003 Jeep Liberty bounced off a Nissan in front of it, rolled onto its side and exploded in flames. Other drivers ran to help but were forced back by the heat. Firefighters arrived in just three minutes but were too late. White, a 23-year-old restaurant hostess who was eight months pregnant, died of burns and smoke inhalation. White is one of more than 70 people killed in fires involving older Jeeps with plastic fuel tanks mounted behind the rear axle. Fiat Chrysler, which makes Jeeps, recalled 1.56 million of them in June 2013 under pressure from US safety regulators. But only 12 percent of the SUVs have been repaired in the 18 months since the recall, a much slower pace than usual. And White's Jeep was not among those fixed. Last week, prosecutors charged the Cadillac driver with committing a moving violation that caused a death. But safety advocates and the lawyer for White's family say the blame belongs as much, if not more, on Chrysler and an auto-industry safety system that moves too slowly to prevent tragedy. The rear-mounted tanks have little structure to protect them if struck from behind, making them susceptible to punctures and fires. Moving the gas tank in front of the axle would be expensive and difficult. So Chrysler's remedy involved installing trailer hitches on the rear of the Jeeps as an extra layer of protection. Government testing showed the hitches protected the tanks in crashes up to 40 mph when stationary Jeeps were hit from behind. But at higher speeds, they wouldn't help. White tried to get the repair done a few weeks before her death but was told by a Jeep dealer that parts weren't available, according to Gerald Thurswell, her family's lawyer. He wouldn't identify the dealership, and his contention could not be independently verified by The Associated Press. Thurswell contends the gas tank ruptured, spilling fuel that touched off the fire. A Chrysler spokesman expressed sympathy to White's family but said the company had no written proof that she asked a dealer about the recall. Two crash reconstruction experts interviewed by the AP say gas wouldn't have spilled from White's Jeep if the tank had been mounted in front of the rear axle. Both say a hitch might have prevented the tank from being damaged, but because both vehicles were in motion, neither expert could say for sure.

164K Jeep Cherokees recalled to protect liftgate from moisture

FCA is recalling 164,003 examples of the 2014 and 2015 Jeep Cherokee because moisture can damage the power liftgate controls on models that are equipped with that feature. Regionally, this includes 99,436 of them in the US, 13,195 in Canada, 2,406 in Mexico, and 48,966 outside of NAFTA. The problem came to light after the automaker started investigating a fire in one of the SUVs. There were no injuries, though. According to FCA US' research, the power hatch's control module potentially can be exposed to water. This can cause a short circuit and possibly a fire, as in this case. Until the issue is repaired, the company is advising owners to keep the cargo area dry on Cherokees equipped with this feature. To fix things, dealers will install a shield around the controls to protect them from moisture and will replace any modules showing exposure to water. Statement: Water-Shield Installation June 24, 2015 , Auburn Hills, Mich. - FCA US LLC is voluntarily recalling an estimated 99,436 SUVs in the U.S. to install shields that protect their power liftgate control modules, and related components, from moisture. FCA US LLC began an investigation after learning of a reported vehicle fire. The probe revealed power liftgate control modules in certain SUVs may be inadvertently exposed to water. This may cause a short-circuit, creating a fire hazard. However, the Company is unaware of any related injuries or accidents. The campaign affects model year 2014 and 2015 Jeep Cherokee SUVs, but is limited to vehicles equipped with power liftgates. An estimated 13,195 customers are affected in Canada, along with an estimated 2,406 customers in Mexico and 48,966 outside the NAFTA region. The estimated total recall population is 164,003. All affected customers will be advised when they may schedule service. If the modules show signs of water exposure, they will be replaced. All recall-related work will be performed free of charge. In the interim, the cargo areas of 2014-15 Cherokees equipped with power liftgates should be monitored and kept dry. Customers with questions may call the FCA US Customer Information Center at 1-800-853-1403.

Stellantis announces ‘Circular Economy’ business to drive revenue, decarbonization

Stellantis has already announced its plans to reach net-zero carbon emissions by 2038. Today, the automaker has announced a new business unit to help it reach that goal while generating 2 billion euros per year in revenue by 2030. The “Circular Economy” business will help make revenue less dependent on finite, rare and ecologically problematic materials. The Circular Economy model features what Stellantis calls a “4R” strategy, comprising remanufacturing, repair, reuse and recycling. The goal is to make materials last as long as they can, reducing reliance on the acquisition of those precious new materials in the future by returning them to the business loop when theyÂ’ve reached the end of their first life. Through these processes, Stellantis says it can save up to 80% raw material and 50% energy compared to manufacturing a new part. Remanufacturing, or “reman” in Stellantis shorthand, means dismantling, cleaning and rebuilding parts to OEM spec. Nearly 12,000 remanufactured parts are available for customers to purchase. Some remanufacturing is done in-house, and some with partners and through joint ventures. Repair is pretty obvious — fixing parts to put back into vehicles. This also consists of reconditioning, to make a vehicle feel like new. Stellantis boasts 21 “e-repair” centers for repairing electric vehicle batteries.  Reuse refers to parts still in good condition from end-of-life vehicles sold as-is. Stellantis says it has 4.5 million multi-brand parts in inventory. These are sold in 155 countries through the B-Parts e-commerce platform. Reuse also refers second-life options, such as using batteries outside of automotive purposes. Recycling involves dismantling parts and scraps back into raw material form that is then looped back into the manufacturing process. Stellantis says it has collected 1 million parts for recycling in the past six months. Recycling doesnÂ’t get counted in that aforementioned 2 billion euros of revenue, but it does save the company money on acquisition of raw materials. As for batteries, specifically, Stellantis expects this recycling business to ramp up after 2030, when the packs currently in service begin to reach the end of their lifecycle. Stellantis will use its new “SUSTAINera” label to denote parts that are offered as part of its Circular Economy business.