1998 Jeep Grand Cherokee Laredo Sport Utility 4-door 4.0l on 2040-cars

Auto blog

NHTSA investigating power modules on Chrysler Group SUVs and minivans

The Center for Auto Safety is officially petitioning the National Highway Traffic Safety Administration to begin scrutinizing alleged problems with the totally integrated power module (TIPM) on about 24 Chrysler Group SUVs and minivans. The advocacy group claims that the part's failure can cause affected vehicles to stall or not start at all. NHTSA is still looking into the accusations and deciding whether a full investigation is actually warranted.
The CAS petition claims at least 70 TIPM failures, but according to NHTSA, six of the complaints are for models that don't have the modules. In 34 of the reported cases, the vehicles refused to start, and in 17 of them the engine stalled. There were also two allegations of smoke and one of a fire. However, none of these affected airbag deployment or resulted in a crash.
This petition isn't the first TIPM-related problem for Chrysler Group. A recent report in the New York Times alleged that it found 240 complaints potentially related to the issue on NHTSA's website alone. In September, the automaker also recalled 230,760 examples worldwide (188,723 in the US) of the 2011 Jeep Grand Cherokee and Dodge Durango replace the fuel pump relay circuit inside of the TIPM-7 with one external to the unit. The original part could allegedly cause the models to stall without warning. Even earlier, the company also recalled about 80,000 examples of the Jeep Wrangler and Dodge Nitro in 2007 to have the module reprogrammed.

Georgia jury awards $150 million in Jeep fire case

FCA US continues to fight allegations that some Jeep Grand Cherokee and Liberty sport-utility vehicles are unsafe because of the possibility of fires in rear-end collisions. In one recently decided case, a jury in Georgia awarded $150 million in damages to a family whose child died in a blaze in 2012 in a 1999 Grand Cherokee. The jury believed that FCA acted with "reckless and wanton disregard," and didn't do enough to warn owners, according to Reuters. The automaker was found liable for 99 percent of the damages, and the remaining one percent was for the driver who rear-ended the family's SUV. In a statement from FCA US, the company said that it is considering an appeal. Under Georgia law, the automaker was allegedly unable to present a three-year investigation of rear-impact data to jurors. This was the same information the National Highway Traffic Safety Administration used to decide that the '99 Grand Cherokee "did not pose an unreasonable risk to motor vehicle safety." The original recall for the models covered 1.56 million examples of the 2002-2007 Liberty and 1993-1998 Grand Cherokee. With the fuel tank located between the rear axle and bumper, NHTSA and FCA eventually agreed to install a trailer hitch for extra protection. A further 1.2 million 1999-2004 Grand Cherokees owners received notice of a customer service action to have their vehicles inspected, though no hitch installed. Subsequent tests showed this remedy to be effective for impacts below 40 miles per hour. The automaker has maintained the SUVs met the applicable safety standards of the period when they were built. The company was chastised by NHTSA last year for low repair rates of the problem. FCA US LLC Statement Regarding Walden v Chrysler Group Verdict: April 2, 2015 , Auburn Hills, Mich. - FCA US is disappointed and will consider an appeal of this verdict. It is unfortunate that under Georgia Law the jury was prevented from taking into account extensive data submitted to NHTSA during a three year investigation, which included more than 20 years of rear impact accident data for tens of millions of vehicles. This and other information provided the basis for NHTSA's determination that the 1999 Jeep Grand Cherokee did not pose an unreasonable risk to motor vehicle safety.

FCA spends $1.5 billion to retool plant for Ram production

Fiat Chrysler Automobiles (FCA) is planning to invest $1.48 billion to retool its Sterling Heights Assembly plant in metro Detroit to build the next generation of the Ram 1500. The investment will allow the assembly plant to go from unibody to body-on-frame construction. FCA also confirmed that production of the Chrysler 200 will end in December in order for the plant to be altered. As previously reported, FCA is looking to move production of the 1500 from its current assembly plant in Warren to the Sterling Heights Assembly plant (both are in Michigan). While FCA has not released any official plans for the Warren Truck Assembly Plant, Automotive News reports that the plant will be retooled to manufacture the Jeep Wagoneer and Grand Wagoneer SUVs. Earlier this month, FCA announced plans to invest $1.05 billion to retool the Jeep Wrangler factory. FCA's current investment plans are part of the automaker's push to put competitive products on the road. Related Video: News Source: FCA, Automotive NewsImage Credit: FCA Plants/Manufacturing Chrysler Jeep RAM SUV Sedan