2014 Sport Altitude Edition New 2l I4 16v Fwd Suv on 2040-cars

Auto blog

NHTSA investigating power modules on Chrysler Group SUVs and minivans

The Center for Auto Safety is officially petitioning the National Highway Traffic Safety Administration to begin scrutinizing alleged problems with the totally integrated power module (TIPM) on about 24 Chrysler Group SUVs and minivans. The advocacy group claims that the part's failure can cause affected vehicles to stall or not start at all. NHTSA is still looking into the accusations and deciding whether a full investigation is actually warranted.
The CAS petition claims at least 70 TIPM failures, but according to NHTSA, six of the complaints are for models that don't have the modules. In 34 of the reported cases, the vehicles refused to start, and in 17 of them the engine stalled. There were also two allegations of smoke and one of a fire. However, none of these affected airbag deployment or resulted in a crash.
This petition isn't the first TIPM-related problem for Chrysler Group. A recent report in the New York Times alleged that it found 240 complaints potentially related to the issue on NHTSA's website alone. In September, the automaker also recalled 230,760 examples worldwide (188,723 in the US) of the 2011 Jeep Grand Cherokee and Dodge Durango replace the fuel pump relay circuit inside of the TIPM-7 with one external to the unit. The original part could allegedly cause the models to stall without warning. Even earlier, the company also recalled about 80,000 examples of the Jeep Wrangler and Dodge Nitro in 2007 to have the module reprogrammed.

7 months later, Jeep 'trailer hitch' recall still stalled

For the past few years, Chrysler and its CEO, Sergio Marchionne, have gone head-to-head with the National Highway Traffic Safety Administration and its boss, David Strickland, over the government safety agency's request for Chrysler to recall almost three-million Jeep vehicles due to what NHTSA says is a safety issue that has caused at least 51 deaths. After a three-year investigation and Chrysler's initial refusal to issue a recall because it deemed the vehicles safe and built to the day's federal requirements, last summer, the two parties compromised on a "voluntary campaign" to inspect 1.56 million vehicles, those being the 1992 to 1998 Grand Cherokee and 2002 to 2007 Liberty.
Those vehicles were designed with their gas tanks between the rear axle and the bumper, and NHTSA says that in rear-end collisions, damage to the fuel tank has caused fires responsible for those 51 deaths. The compromise reached last summer was that Chrysler would inspect 1.56 million vehicles and, "if necessary, provide an upgrade to the rear structure of the vehicle." Practically speaking, that meant Chrysler would replace aftermarket trailer hitches, but would take no action if a vehicle had a factory-installed hitch or an aftermarket hitch from Mopar.
A report in The Detroit News says the "voluntary campaign" is just now getting under way, with Chrysler saying last week that the design of the replacement part had been finalized and it was tooling up "to deliver the required volume." Seven months later, still in question is whether NHTSA will crash-test the fix engineered by Chrysler, noteworthy because not only did the vehicles in question pass every safety standard necessary to be cleared for sale at the time, there are still questions (to those of us on the outside) as to how the Jeeps at issue fare among their peers in such incidents. Either way, Chrysler and NHTSA apparently still disagree on the efficacy of the remedy itself: the carmaker says it might help in low-speed crashes but not high-speed collisions, a position the NHTSA is at odds with. All of this means the campaign doesn't yet have an end in sight.

FCA plotting larger Jeep Renegade, Fiat 500XL

The joint development of the new Jeep Renegade and Fiat 500X goes to show what the combined efforts of the Fiat Chrysler Automobiles group can yield. But don't expect the Italian-American automaker to stop there. According to Autocar, the company is planning to base another pair of larger SUVs on the same platform. The Jeep version would take the place of the previous Compass and Patriot, slotting in between the Renegade and Cherokee. Meanwhile, the Fiat version would further bolster the Cinquecento lineup to sit alongside the 500 hatchback, 500L minivan and 500X crossover. Details remain few and far between at the moment, but they wouldn't be the extent of the growth plans for either brand. Jeep is reportedly zeroing in on a decision on the long-rumored sub-Renegade model, while also preparing to expand up-market with the return of the Grand Wagoneer. Fiat is reportedly abandoning the prospect of offering a full model line as it once did. While the 500 range will continue to form a vital part of the brand's business, it's also tipped to be going after the no-frills, bare-bones market dominated by Renault's Dacia brand. To that end, it would seek to build upon the Panda by offering a larger, but still low-cost hatchback to rival the Ford Focus and VW Golf, and succeed the discontinued Fiat Bravo, but based on the 500L's platform and built in Turkey to keep costs down. This second pillar of the Fiat brand wouldn't likely be offered in the US, however, where we'd expect the 500 line to continue representing the Italian automaker. Related Video: