1994 Jeep Cherokee Sport Sport Utility 4-door 4.0l Auto Trans- 4 Wheel Drive !!! on 2040-cars

Auto blog

Chrysler taking big risk snubbing NHTSA

Maker Insists Feds Overstate Risk Of Fires With Grand Cherokee, Liberty Models
It's not often that recall stories make it above the fold, in that old newspaper parlance, but when one shows up as the lead story on the network evening news programs, you know it's something big.
And so it is with Chrysler snubbing its nose at a request by the National Highway Traffic Safety Administration to recall 2.7 million Jeeps the feds insist are at risk of potentially catastrophic fuel tank fires in a rear-end collision.

7 months later, Jeep 'trailer hitch' recall still stalled

For the past few years, Chrysler and its CEO, Sergio Marchionne, have gone head-to-head with the National Highway Traffic Safety Administration and its boss, David Strickland, over the government safety agency's request for Chrysler to recall almost three-million Jeep vehicles due to what NHTSA says is a safety issue that has caused at least 51 deaths. After a three-year investigation and Chrysler's initial refusal to issue a recall because it deemed the vehicles safe and built to the day's federal requirements, last summer, the two parties compromised on a "voluntary campaign" to inspect 1.56 million vehicles, those being the 1992 to 1998 Grand Cherokee and 2002 to 2007 Liberty.
Those vehicles were designed with their gas tanks between the rear axle and the bumper, and NHTSA says that in rear-end collisions, damage to the fuel tank has caused fires responsible for those 51 deaths. The compromise reached last summer was that Chrysler would inspect 1.56 million vehicles and, "if necessary, provide an upgrade to the rear structure of the vehicle." Practically speaking, that meant Chrysler would replace aftermarket trailer hitches, but would take no action if a vehicle had a factory-installed hitch or an aftermarket hitch from Mopar.
A report in The Detroit News says the "voluntary campaign" is just now getting under way, with Chrysler saying last week that the design of the replacement part had been finalized and it was tooling up "to deliver the required volume." Seven months later, still in question is whether NHTSA will crash-test the fix engineered by Chrysler, noteworthy because not only did the vehicles in question pass every safety standard necessary to be cleared for sale at the time, there are still questions (to those of us on the outside) as to how the Jeeps at issue fare among their peers in such incidents. Either way, Chrysler and NHTSA apparently still disagree on the efficacy of the remedy itself: the carmaker says it might help in low-speed crashes but not high-speed collisions, a position the NHTSA is at odds with. All of this means the campaign doesn't yet have an end in sight.

Jeep to stop using bad Takata airbag inflators next week

FCA is gradually ceasing to produce vehicles equipped with Takata airbag inflaters found to be inherently faulty. These airbags, which lack a certain drying agent, have been linked with dangerous premature ruptures. According to FCA, the only vehicle still in production with the named airbag is the 2016 Jeep Wrangler, and in this case they are passenger-side airbags. Fiat Chrysler says it isn't aware of any incidents involving these air bag inflaters in Jeeps, but amidst concerns that vehicles with failure-prone airbags are still being marketed to customers, North American-market 2016 Wranglers will cease to be equipped with them starting next week. As per FCA's statement, global production is expected to end by mid-September. In addition to Toledo, Ohio, the Wrangler is produced in Egypt. FCA isn't going to sell the cars with the deemed-faulty airbags without disclosing the fact to the customers: anyone buying a 2016 Wrangler will be notified that the vehicle will most likely be subject to a recall in the future, even if there is not currently a recall announced for them. NHTSA has specified a "Coordinated Remedy Program" recall schedule for the coming years, and the airbag inflaters will degrade over a time frame of several years, when subjected to a humid environment. Related Video: News Source: Fiat Chrysler Automobiles, The Wall Street JournalImage Credit: Julien Amado / Autoblog Quebec Plants/Manufacturing Recalls Chrysler Jeep Ownership Safety Takata airbag recall