Hummer H1 Cummins Turbo Diesel Predator Elite Series Custom Conversion on 2040-cars

Auto blog

Why didn't GM recall fire-prone Hummers earlier?

As early as 2009, motorists reported fires in the Hummer H3. In a complaint filed that March with the regulatory agency in charge of vehicle safety, one motorist said they leaped into a smoldering vehicle and drove it away from gas pumps moments before it was engulfed in flames. Three months later, another motorist described how a fire spread from behind the glove box and consumed their H3. Dozens of car owners filed similar complaints with the National Highway Traffic Safety Administration in the six years that followed, detailing car fires of varying severity that originated in the HVAC systems of their Hummer H3s. But General Motors didn't issue a recall for any of the affected cars until last week, prompting fresh questions about how the company treats safety concerns in the wake of an ignition-switch flaw that went unaddressed for years and, at latest count, is responsible for killing at least 124 motorists. In recall documents filed with NHTSA last week, GM initially said it knew of three fires associated with the defect. Within hours, the company said it knew of 42 fires associated with the problem and three injuries sustained by vehicle occupants. A company spokesperson attributed the inconsistency to a "misstated" number in the original documents and that the higher number comes from NHTSA complaints, reports to GM and TREAD data. Beyond that discrepancy, the documents show General Motors, which has touted a revitalized attitude toward safety concerns since the ignition-switch recalls, did nothing upon determining there was a problem with the H3s. Prompted by two complaints the company received in September 2014, General Motors says it launched an internal investigation related to melting blowers in the HVAC system on December 8, 2014. In that investigation, the company says it confirmed a problem existed, finding that "mismatched electrical conductivity could result in overheating and melting of the blower motor connector module." But even with that conclusion, the company opted to close its internal investigation on April 29, 2015, without taking any action. It wasn't until NHTSA officials met with GM representatives in a meeting on June 18, 2015, that General Motors was prompted to reconsider.

GMC Hummer EV recalled over improperly sealed battery pack

Over 700 units of the GMC Hummer EV built during the 2022 and 2023 model years will be recalled due to an improperly sealed battery pack that lets water in. The firm issued a stop-delivery order at the same time as the recall, and it hasn't found how to fix the problem yet. Assigned recall number 22V-771 by the National Highway Traffic Safety Administration (NHTSA), the campaign includes 735 examples of the Hummer EV and 89 units of the BrightDrop Zevo 600 van. These two vehicles are pegged on opposite ends of the automotive spectrum, but they're affected by the same problem: "the high-voltage battery pack enclosure in some of these vehicles may not have been properly sealed," GMC notes, adding that "flanges on the battery pack enclosure may not have been properly primed or electrocoated." Water can wreak havoc in a high-voltage battery pack. GMC told NHTSA that it has found three EVs with this problem: an internal test vehicle that lost power while driving and two customer-owned vehicles that wouldn't start. As of writing, the firm is not aware of any accidents, injuries, or fires related to the issue, and GMC estimates that only about 1% of the recalled EVs are affected. GMC began notifying dealers of the recall in October 2022, and it plans to start reaching out to owners on November 28, 2022. However, a fix hasn't been found yet. In the meantime, the company issued a stop-delivery order and asked dealers not to attempt their own repairs. This isn't the Hummer EV's first run-in with water-related problems. In August 2022, General Motors voluntarily recalled 424 units of the Hummer EV and the Zevo 600 van due to a high-voltage connector that can prematurely corrode. The problem also let water leak into the battery pack, though it sounds like fixing it was reasonably straight-forward and involved applying sealant to the connector. Related video: This content is hosted by a third party. To view it, please update your privacy preferences. Manage Settings. Featured Gallery 2022 GMC Hummer EV Edition 1 First Drive View 17 Photos Green GMC Hummer Truck Electric

Texas sues GM, saying it tricked customers into sharing driving data sold to insurers

Texas filed a lawsuit Tuesday against GM over years of alleged abuse of customers' data and trust. New car owners were presented with a "confusing and highly misleading" process that was implied to be for their safety, but "was no more than a deceptively designed sales flow" that surrendered their data for GM to sell. The suit contends that at no point was selling driving data ever even suggested as a possibility, putting GM in violation of the state's consumer protection laws. Texas Attorney General Ken Paxton is seeking a jury trial and at least $10,000 per offense (every GM car sold in the state since 2015) and a hefty add-on of $250,000 in cases where the victim was over 65. Texas seems to be flying high after a recent $1.4 billion settlement from Meta over other privacy concerns. This may well be a way to solve any pending budgetary issues in the Lone Star State.