Ford Mustang Convertable on 2040-cars

Auto blog

Ford recalls nearly 200,000 Expeditions and Navigators for fire risk

Ford is recalling 2015-2017 Expeditions and 2015-2017 Lincoln Navigators because the front blower motor could fail and cause a fire. In total, 198,482 Expeditions and Navigators will be recalled. In the official recall documents posted by NHTSA, Ford says that it “has not identified the cause of this condition.” However, Ford also says it is currently aware of 25 fire allegations related to the blower motors on these vehicles. Despite not strictly identifying the cause of blower motor fires, Ford put forth a theory in its fieldwork analysis of the issue.  “In June 2022, based on component analysis, Ford Engineering theorized that a mispositioned blower motor brush holder spring could cause an internal short or localized heating of the brush spring or holder. It is believed that when a fire initiates on the blower motor, it does so at the positive brush holder location. The variable blower controller would remain operational and there would be no signs of an overheated relay. Field data indicates that this concern typically occurs at a higher time in service, and on vehicles with higher mileage.” Since the blower motor is located on the passenger side interior behind the glovebox, the fires that start are interior fires. Ford isnÂ’t aware of any accidents related to this issue, but there is one claim of burnt hands and fingers as a result of a fire. According to Ford, warning signs of an impending fire or failed blower motor include an inoperative fan, burning smell and/or smoke from the instrument panel vents while the vehicle is on. To remedy this situation, Ford is recalling the affected SUVs and replacing the blower motor assembly with a revised part. The new part uses a blower motor assembly design utilized on other applications. If folks with these SUVs experience any symptoms of blower motor failure before the new part becomes available, Ford says they can take their vehicle to the dealer to have it replaced with a part of the same design. Once the redesigned part becomes available, the dealer will then swap it in. Owner notification letters are expected to begin on September 12 this year. Related video: This content is hosted by a third party. To view it, please update your privacy preferences. Manage Settings.

FBI Seizes Computers, Listening Devices From Ford Headquarters

FBI agents searched Ford Motor Company's headquarters in Dearborn, Michigan, this month as part of an investigation into possible corporate espionage. Eight devices, along with documents, computers and financial records, were among the items seized by federal agents on July 11, according to documents obtained by The Detroit News. The FBI searched Leach's home on June 20 and seized more than two dozen items in that search, Reuters reported. Former engineer Sharon Leach, a 17-year Ford veteran of company, was fired last month, according to The News, which first reported the story. She admitted to placing recording devices under conference tables before meetings. She told Ford security she used the recordings to assist in her meeting notes. She couldn't remove the devices after meetings without drawing attention to herself, leaving the devices to record other meetings. Leach has not been charged for any wrongdoing. Former federal prosecutor and Wayne State University law professor Peter Henning told The News that using a search warrant, rather than a subpoena, shows the FBI suspects more employees could be implicated. "If it's an economic espionage case or trade-secrets case, that rarely involves one individual," Henning told The Detroit News. "So the concern is if you send a subpoena and ask for recording devices, those things can be erased." Leach, Ford and the FBI declined to comment on the investigation. Related Gallery AOL Autos Test Drive: 2014 Ford Fiesta ST Auto News Ford espionage corporate

Toyota, Ford not interested in FCA merger

Sergio Marchionne will preach the benefits of mergers to anyone who'll listen, but his calls for industry consolidation may be falling on deaf ears. At least, that is, the ears of those who the Fiat Chrysler chief would most like to bend. Not only is General Motors uninterested, but according to The Detroit News, neither are Toyota or Ford. "It's something we would not be interested in," said Toyota's North American chief Jim Lentz, at the groundbreaking ceremony for the new Toyota Technical Center. "At 10 million (vehicles) we have enough scale right now to do what we need to do. There really would be no advantage for us." Toyota isn't the only one unenthused by the prospect of merging with Fiat Chrysler Automobiles. The Detroit News also reports that Ford, though it may yet to have been approached by Marchionne, wouldn't be interested either. "We're not a suitor for FCA," said Ford CFO Bob Shanks. "We don't see that type of opportunity as one that applies to us." With GM, Toyota, and Ford expressing disinterest in Marchionne's merger idea, the FCA chief will likely start looking elsewhere – or look for other ways to compel his primary candidate to reconsider. He may eventually find a partner – more likely in the Far East or within Europe – but it may not take the form of the major player Sergio has hoped for. News Source: The Detroit NewsImage Credit: Bill Pugliano/Getty Chrysler Fiat Ford Toyota Sergio Marchionne FCA merger fiat chrysler automobiles