1967 Ford Mustang Fastback on 2040-cars

Auto blog

2020 Ford Explorer, Lincoln Aviator reportedly facing numerous QC issues

A lengthy report in the Detroit Free Press delves into a range of quality control issues confronting the 2020 Ford Explorer and its luxury platform sibling, the 2020 Lincoln Aviator. Freep says it's been following the issue for two months, tapping various unnamed sources for information on the automaker's unorthodox route to resolution. Seems the problem is Explorers and Aviators leaving the production line at the Chicago Assembly Plant with flaws in areas like the chassis, transmission and suspension, said vehicles trucked to Ford's Flat Rock Assembly Plant (FRAP) outside of Detroit for repair. The estimates range from 10,000 to 18,000 vehicles affected, numbers so high that Ford has sought help from Roush Engineering in nearby Allen Park, and brought workers and managers from other plants in the Midwest to FRAP to get vehicles repaired and shipped to dealers. Ford hasn't shared the nature of the problems with anyone outside the company, including dealers and customers. Freep's sources are said to include workers who have provided photos of certain vehicles and of tents used to house parts at the FRAP repair site. The Explorer chassis allegedly has an unidentified problem that engineers are using X-rays to diagnose, and the transmission is having problems sensing when it's in park or going into park. Both the Explorer and Aviator have come off the line with HVAC units that only blow hot air. And the Aviator's height-adjustable suspension enters failure mode for unknown reasons. These come on top of quotidian mishaps common to every new vehicle, but that are meant to be sorted in pre-production, like missing emblems and trim pieces. They also come on top of a recall in early August issued for the Explorer and Aviator concerning the instrument cluster and parking brake, and another at the end of August over rear seatbacks that could collapse in a crash. An automaker spokesperson told Freep, "Making updates to preproduction models based on all-new platforms as they roll off the assembly line – is standard industry practice." Except these aren't pre-production, these are early production vehicles that paying customers and dealers are waiting for, and some of the affected vehicles have been pulled off dealer lots. Dealers say they are fine waiting for the trucks to get sorted out, and they'd rather have Ford fix the problems before the SUVs go to customers.

How Ford made its 2015 Ford Mustang safer for toupee wearers [w/video]

Ford is ready to tell the story of its 2015 Mustang Convertible, the can't-miss bits being the easier, quicker and quieter roof operation, a more robust roof build for a coupe-like cabin noise, more trunk space, better visibility and reduced in-cabin buffeting. The top release system has been completely redesigned with a single, center-mounted latch on the windshield frame instead of the dual latches of before. The driver can now release the roof without having to lean over into the passenger space, after which the top goes down fully automatically with the press of a button. Ford doesn't say how long it takes to stow, but it's apparently done in half as much time as before, so figure around 8 seconds.
The roof uses a five-bow structure, with the fabric outer and full inner headliner sandwiching ten millimeters of insulation. Detailing work on the top has eliminated "unsightly folds" in the corners when the roof is up and made it more compact when down; its Z-fold assembly is 6.7 inches lower than before at its highest point when put down. Ford says the new electric drive internals make less noise when in operation, and the fully-finished droptop look is achieved with snap-in caps that flank the rear seating and stow in the trunk when not in use (the outgoing Mustang's top was higher and the front when folded and always looked like it was catching air and creating drag).
The compact roof and newly independent rear suspension setup in back means liberated trunk space, 11.4 cubic feet ready to swallow golf bags and tourist swag. You can read a lot more about it in the press release below, check it out in the short video of running footage and learn about the aerodynamic improvements made to the entire Mustang lineup that decrease drag and increase fuel economy.

Kawei K1 pickup blatantly copies Ford F-150

The Chinese auto industry used to be looked at as a joke full of products blatantly copied from foreign vehicles. However, companies like Qoros and others show that the country's automakers have taken big steps in terms of original design. It doesn't look like every automaker there is ready to put down the tracing paper yet, though. Case in point: The Kawei K1 pickup pictured above, which is an obvious rip-off of the Ford F-150. In fact, the company isn't even hiding it. Kawei deserves a little credit for its openness. In describing the new model, it says: "No matter the black net grille and the outline of the headlamp, even if the styles of fog lamp and engine cover, it looks the same as Ford Raptor." It also admits that spelling out the model name on the hood is inspired by Land Rover. It's available with either a 2.4-liter, gasoline-fueled four-cylinder producing 141 horsepower and 148 pound-feet of torque (elsewhere it also lists it as having 162 lb-ft) or a 3.2-liter six-cylinder diesel with 106 hp and 181 lb-ft. Regardless of engine, power is sent to the rear wheels through a five-speed manual gearbox. The trucks cost around 100,000 Yuan ($16,033). So at least the K1 is a reasonably priced knockoff. According to Car News China, the K1 is actually selling in small numbers. The company made 10,000 of them last year and even exported some to Africa and the Middle East. Kawei's factory is doubling in capacity this year to build even more. You can read more about the truck on the company's website in some very mangled English. Featured Gallery Kawei K1 Pickup View 11 Photos News Source: Kawei via Car News ChinaImage Credit: Kawei Beijing Motor Show Ford Truck Diesel Vehicles Beijing 2014