1963 Ford Galaxie on 2040-cars

Auto blog

Ford expands door-latch recall to 156k more vehicles, nearly 550k total

Ford is being inundated with recalls as of late. Just days ago it called in over 590,000 cars for a variety of issues. Now, the Blue Oval has announced an expansion of its door latch campaign to cover an additional 156,000 vehicles in North America. Counting the original 389,585 cars, this has brought the total to 545,906. Under this expansion, the same models are affected, but Ford is broadening the coverage dates in some cases. The recall covers the 2011-2014 Fiesta, 2013-2014 Fusion, and 2013-2014 Lincoln MKZ; there are 456,440 units in the US, 50,681 in Canada, and 38,785 in Mexico in need of repair. In these vehicles, a door might not latch because of a broken pawl spring tab. Even if a passenger can successfully close it, the faulty part could unlatch while driving. According to Ford, there are two allegations of doors bounding back and hitting a person. There's also one possible accident from a door opening and striking another vehicle. Dealers will replace all of the latches to fix the problem. Related Video: MAY 1, 2015 | DEARBORN, MICH. FORD EXPANDS DOOR LATCH SAFETY RECALL IN NORTH AMERICA DEARBORN, Mich., May 1, 2015 – Ford Motor Company is expanding a safety recall regarding door latches to include approximately 156,000 more vehicles at the request of the National Highway Traffic Safety Administration, bringing the total to 545,906 vehicles in North America. The door latch in certain vehicles may experience a broken pawl spring tab, which typically results in a condition where the door will not latch. If a customer is then able to latch the door, there is a potential the door may unlatch while driving, increasing the risk of injury. Ford is aware of a total two allegations of soreness resulting from an unlatched door bouncing back when the customer attempted to close it, and one accident allegation when an unlatched door swung open and struck the adjacent vehicle as the driver was pulling into a parking space. Affected vehicles include certain 2011-14 Fiesta vehicles built at Cuautitlan Assembly Plant, Nov. 3, 2009 to May 31, 2013; certain 2013-14 Fusion vehicles built at Hermosillo Assembly Plant, Feb. 1, 2012 to May 31, 2013; certain 2014 Fusion vehicles built at Flat Rock Assembly Plant, April 12, 2013 to April 26, 2013; and certain 2013-14 Lincoln MKZ vehicles built at Hermosillo Assembly Plant, Feb. 1, 2012 to May 31, 2013. There are 456,440 vehicles in the United States and federalized territories, 50,681 in Canada and 38,785 in Mexico.

How Ford made its 2015 Ford Mustang safer for toupee wearers [w/video]

Ford is ready to tell the story of its 2015 Mustang Convertible, the can't-miss bits being the easier, quicker and quieter roof operation, a more robust roof build for a coupe-like cabin noise, more trunk space, better visibility and reduced in-cabin buffeting. The top release system has been completely redesigned with a single, center-mounted latch on the windshield frame instead of the dual latches of before. The driver can now release the roof without having to lean over into the passenger space, after which the top goes down fully automatically with the press of a button. Ford doesn't say how long it takes to stow, but it's apparently done in half as much time as before, so figure around 8 seconds.
The roof uses a five-bow structure, with the fabric outer and full inner headliner sandwiching ten millimeters of insulation. Detailing work on the top has eliminated "unsightly folds" in the corners when the roof is up and made it more compact when down; its Z-fold assembly is 6.7 inches lower than before at its highest point when put down. Ford says the new electric drive internals make less noise when in operation, and the fully-finished droptop look is achieved with snap-in caps that flank the rear seating and stow in the trunk when not in use (the outgoing Mustang's top was higher and the front when folded and always looked like it was catching air and creating drag).
The compact roof and newly independent rear suspension setup in back means liberated trunk space, 11.4 cubic feet ready to swallow golf bags and tourist swag. You can read a lot more about it in the press release below, check it out in the short video of running footage and learn about the aerodynamic improvements made to the entire Mustang lineup that decrease drag and increase fuel economy.

Ford wins second consecutive Engine of the Year with 1.0L EcoBoost [UPDATE]

For the second year in a row, Ford has taken top honors in International Engine of the Year voting. As was the case last year, it is Ford's 1.0-liter EcoBoost engine that earns the automaker the accolade, achieving the highest-ever accumulated score in the 15 years that the award has been handed out.
A panel of 87 automotive journalists from 35 countries are responsible for choosing the world's best engines, and this is only the third time an automaker has managed back-to-back victories. Voters were impressed by the "Baby EcoBoost" engine's power output - 123 horsepower between 1,400 and 4,500 rpm, 148 pound-feet of torque from 1,400 to 4,000 rpm - and its compact size; Ford has demonstrated that the package is small enough to fit in the overhead bin of a passenger airplane.
Currently, the 1.0-liter EcoBoost is offered in the European Fiesta, B-MAX, Focus, C-MAX and Grand C-MAX, and Ford plans to put the engine in the Transit Connect, Transit Courier, Tourneo Connect, Tourneo Courier, Mondeo and EcoSport in short order. In North America, the Fiesta will be the first vehicle to offer the 1.0L EcoBoost later this year.