2012 Ford F-250 Reg Cab 4x4 6.2l V8 Fx4 Long Bed 13k Mi Texas Direct Auto on 2040-cars

Auto blog

Ford recalls 591,177 vehicles in four separate campaigns

Ford is issuing recalls for a total of 591,177 vehicles worldwide, in four separate campaigns. The announcement comes just days after the discovery of door-latch problems in 390,000 of the automaker's cars. The largest of these new recalls covers 518,313 examples of the Ford Fusion and Lincoln MKZ from the 2013-2015 model years, plus the 2015 Edge. Of these, 487,301 of are in the US and 31,012 are in Canada. For vehicles in cold-weather areas, the bolts that hold the steering gear motor can corrode and fracture. If this happens, it could cause the power steering to fail, but manual control would be retained. There are no reported accidents or injuries from this problem. To fix things, dealers will replace the bolts and seal them. The next campaign covers 50,157 examples of the 2014 Focus, Edge, Escape, and Transit Connect, plus the Fiesta from 2014 and 2015. Of these, 45,505 are in the US, 4,618 in Canada, and 34 in Mexico. All of them exhibit a problem with the fuel pump where the nickel plating can cause the part to seize and the engine to stall, if this occurs. (All of which sounds like recent problems with Nissan and BMW models.) According to Ford, there is one allegation of an accident from this problem. Dealers will replace the fuel delivery module to fix the problem. Ford is also recalling 22,616 units of the 2015 Lincoln MKZ because when the headlights are on, the parking lamps are brighter than they are allowed to be. The light could affect the vision of other drivers. This campaign includes 21,435 of them in the US, 1,066 in Canada and 115 in Mexico. There are no accidents or injuries from the issue, but Ford is updating the software to dim the lights on these sedans. Finally, Ford has a safety campaign for 91 examples of the 2015 F-150 because an underbody heat shield might not be properly installed or not present at all, which can be a fire risk. There are no reports of any actual accidents or fires, though. The affected pickups will have the parts replaced or added, as necessary after a dealer inspection. To see the specific build dates for the models affected by each of these campaigns, you can read about them in the press release below. Related Video: FORD ISSUES FOUR SAFETY RECALLS IN NORTH AMERICA Ford Motor Company is issuing four safety recalls in North America. One accident and no injuries are attributed to these conditions.

Ford F-150 EcoBoost in NHTSA probe for acceleration issue

According to Automotive News, the National Highway Traffic Safety Administration is launching a probe into 400,000 Ford F-150 models over possible acceleration problems. According to the article, NHTSA has received 95 reports "alleging incidents of reduced engine power during hard accelerations" on 2011 to 2013 F-150 models equipped with the company's 3.5-liter EcoBoost V6 engine.
Automotive News reports that Ford has issued three technical service bulletins "related to intermittent stumble/misfire on acceleration from highway cruise in humid or damp conditions," according to the government agency's documents. About one third of the 95 reports NHTSA has received cited humid or rainy conditions when these problems allegedly occurred.
These technical service bulletins have allowed dealers to address a "condition related to moisture accumulation in the charge air cooler during extended highway cruising at constant throttle in humid or damp conditions," AN reports, citing NHTSA documents. Furthermore, the TSB outlines details for "reprogramming the powertrain control module with the latest calibration and installing a new CAC and air deflector plate."

Monsoon rains disrupt production for Ford, BMW in India

Even modern production techniques can be stymied by Mother Nature. This was demonstrated most recently in India, as torrential, monsoon rains caused a deluge that forced multiple automakers to suspend production. Ford, Renault, and BMW all halted work at their Indian facilities around the southern city of Chennai, also known as Madras. The annual rains disrupted public transport around the city, preventing employees from making the trek into city's factories. According to Automotive News, Chennai saw 48 inches of precipitation last month alone, which is more than Seattle, WA saw in all of 2014. While Ford and BMW closed things down for all of December 1, Renault just cancelled a pair of shifts at its Chennai factory. This is the second time in the past month that automakers in southeast India have been forced to stop production due to severe flooding, and things aren't likely to improve. According to The Weather Channel, forecasts call for thunderstorms over five of the next seven days, while the chance of rain won't fall below 80 percent until December 8. Ford, Renault, and BMW are far from the only automakers that could stand to be impacted by the rains. The city has been nicknamed "The Detroit of India" for its extreme automotive presence. Daimler, Hindustan, Hyundai, Mitsubishi, and Nissan all own factories in the region. News Source: Automotive News - sub. req.Image Credit: STR / AFP / Getty Images Plants/Manufacturing BMW Ford Renault