2014 Ford F150 Xl on 2040-cars

Auto blog

Ford announces first non-pursuit-rated police car ever

Ford announced its first non-pursuit-rated Police Interceptor ever, based on the Taurus, which employs the smaller 2.0-liter EcoBoost four-cylinder engine in place of similar pursuit-rated Police Interceptors powered by naturally aspirated 3.5-liter and 3.7-liter V6s and the top-spec 3.5-liter EcoBoost V6. Officially called the Special Service Police sedan, the car was commissioned at the request of law-enforcement agencies that desire a more fuel-efficient vehicle for detectives, administrators and campus police, who don't necessarily need pursuit-rated vehicles.
The 2.0-liter EcoBoost engine produces 240 horsepower and 270 pound-feet of torque, but more importantly, it allows the SSP sedan to achieve somewhere in the neighborhood of 22 miles per gallon city and 32 mpg highway, which are the civilian 2.0-liter Taurus' official EPA ratings. Ford estimates that the SSP sedan will get 20 mpg city, 30 mpg highway and 23 mpg combined, with the help of Active Grille Shutters that open to allow more cooling air through to the radiator, or close to optimize aerodynamics and fuel economy. Those numbers compare favorably to the discontinued Crown Victoria-based Interceptor's 14 mpg city and 21 mpg highway and the newer Taurus-based cars equipped with V6s, the most fuel efficient of which gets 18 mpg city and 26 mpg highway.
If it was driven 90,000 miles over the course of three years, a 2.0-liter SSP sedan would save law enforcement agencies $5,042.92 versus the Crown Vic, Ford estimates. The EPA is expected to post official fuel-economy numbers for the SSP sedan in December. Until then, read the press release below for more information.

NHTSA upgrades Ford floor mat unintended acceleration probe

According to a Bloomberg report, the National Highway Traffic Safety Administration has upgraded an investigation into complaints of unintended acceleration lodged against Ford vehicles. The investigation began in June of 2010 when just three complaints had been received and it only concerned the Ford Fusion and Mercury Milan, but this was at a time when the phrase "unintended acceleration" made grown men go pale. With 49 additional complaints received since then, the investigation has been reclassified as an engineering analysis - the last phase before a recall - and it has been expanded to include the Lincoln MKZ, making for a total of "around 480,000" units affected between the three sedans from the 2008 to 2010 model years.
The ostensible cause is that floor mats are trapping the accelerator pedal, but according to a Ford statement at the time, the entrapment is due to owners placing the optional all-weather floor mats, or aftermarket floor mats, on top of the car's standard floor mats. NHTSA has backed up that assessment, pinning the blame on "unsecured or double stacked floor mats."
On the face of it, it would appear that NHTSA has upgraded the status not because of Ford's error, but owner error, and Ford has stated publicly that it is "disappointed" in NHTSA's move. On top of NHTSA still being skittish after that other unintended acceleration debacle, it could be seen to be taking its time investigating all of the variables: it's reported that Ford changed its accelerator pedal design in 2010, a "heel blocker" in the floorpan has been considered a potential culprit in how the floor mats could be trapping the pedal, some drivers have said the floor mats weren't anywhere near the pedal, and according to a report in the LA Times, in "a letter sent by Ford to NHTSA in August 2010, the automaker said it found three injuries and one fatality that 'may have resulted from the alleged defect.'"

GM readying aluminum-body fullsize pickups

Ford's extensive use of aluminum in its 2015 F-150 is a big deal. A really big deal. Big enough, in fact, that General Motors is reportedly changing its fullsize pickup strategy. According to The Wall Street Journal, The General has locked in partnerships with Alcoa Inc. and Novelis Inc. - companies that will supply aluminum for the next-generation Chevrolet Silverado and GMC Sierra trucks.
"Ford's introduction of the 2015 F-150 pickup truck was a game changer, and it's the first, not the last, conversion of this type," Novelis spokesperson Charles Belbin told the Journal. The switch to aluminum has allowed Ford to shave roughly 700 pounds off its fullsize truck's curb weight. And while official mileage ratings have not been announced, the weight loss should go a long way for improving efficiency, especially when combined other efficiency-minded improvements including better aerodynamics and new, turbocharged V6 engines.
Of course, aluminum-bodied cars are nothing new. But extensive use of aluminum in a major, best-selling product like the Ford F-150 is expected to kick off widespread use of this weight-saving material as availability rises and cost decreases. The WSJ reports that GM had originally explored the idea of moving to aluminum pickups back in 2008, but abandoned the idea due to cost concerns amid economic woes.