2001 Ford Expedition Xlt (40757b) ~~ As Is Special! on 2040-cars

Auto blog

Ford opens the doors on its Swedish rally skunkworks

It's always amazing to see how different kinds of racecars are made. Formula One racers are often constructed in modern architectural marvels that hint at some of the cutting-edge technology going into the racing. Conversely, rallying is all about sliding around on a varied course as fast as possible, but it often leaves a vehicle caked in mud. So it makes some sense Olsbergs MSE, or simply (OMSE) rally car shop in Nynashamn, Sweden, shows technological sophistication in a more down-to-earth setting. It builds Ford Fiesta ST racers for Global Rallycross there, and this new video gives viewers a tour through the work.
Former rally driver Andreas Eriksson runs OMSE. These days instead of racing, he and the company's 46 employees are building Ford racers from scratch. A ton of work goes into constructing each one, and according to Eriksson, it takes 400 hours to complete each body. At times, things are so busy that some of the technicians live in the shop in apartments that are on premises. There's even a restaurant to keep them fed. Sadly the dyno room is empty during this visit, though.
By the time OMSE is done, a rallycross car might resemble a Fiesta ST on the outside, but as you see in the video, it's a completely different beast underneath. Check out the work it takes to build one of them, and scroll down to read more about it in the official release.

NHTSA closes investigations into Ford Taurus, Hyundai Santa Fe

Ford and Hyundai are out from under the scrutinizing eyes of the National Highway Traffic Safety Administration after the government agency said it was closing investigations against both automakers over vehicle safety concerns.
Ford was being investigated for reported damaged speed control cables on Ford Taurus (shown above) and Mercury Sable models, both built between 2000 and 2003. Vehicles with the company's Duratec engines allegedly failed to allow owners to brake as expected. Owners lodged 100 complaints and were involved in five accidents, according to NHTSA records. The American automaker responded to the reports, and on June 21 of this year, said that it would inspect and repair all affected vehicles, regardless of the mileage.
Hyundai was under investigation for a reported loose fastener on the steering shaft of its 2011 Santa Fe (shown in the gallery below). After NHTSA launched its inquiry, the Korean automaker responded with its own investigation that yielded four affected vehicles. Following the inspection of 680 vehicles at its assembly plant, Hyundai said the issue was due to employee error and that no further defects have been found.

Ford nets $5.7B in 2012, $1.6B in fourth quarter

Ford brought in $5.7 billion in net income during 2012, which is around $307 million less than one year prior. Even so, the automaker closed out 2012 with the highest pre-tax profit for a single quarter in nearly 10 years, earning $1.7 billion in the fourth quarter thanks largely to a higher-than-average truck mix in the US. That's a jump of $577 million over 2011. Likewise, that translated into fourth quarter income of $1.6 billion. All told, Ford set a full-year pre-tax profit record in 2012. But that doesn't necessarily mean everything is rosy in the land of the Blue Oval.
Like every other manufacturer, 2012 saw Ford get hammered in the European Union, where a deep economic recession continues to drive down consumer confidence. The automaker lost more than $700 million in Europe, and saw full revenue of $26.6 billion in 2012. That's a decline of $7.2 billion compared to last yea. Ford says the market for new vehicles in Europe has contracted to 13.5 million units, the lowest number in 17 years. You can read the full press release below for more information.