1999 Ford Handicap Cutaway Van Seats 13, Runs Great on 2040-cars

Auto blog

Feds Probe Power Steering In 938,000 Ford Midsize Cars

U.S. safety regulators are investigating complaints that the power-assisted steering can suddenly fail on three Ford midsize car models. The probe covers 938,000 Ford Fusion and Lincoln MKZ cars from the 2010 through 2012 model years, as well as the 2010 and 2011 Mercury Milan. The National Highway Traffic Safety Administration says it has received 508 complaints alleging that the cars lost power-assisted steering, causing increased steering effort. Four complaints say the problem caused crashes, but no injuries were reported. The agency says in documents posted Monday on its website that in many cases, a warning message appeared as the failure happened. Restarting the car corrected the problem in some cases, but the problem returned in others. The agency says it will check the scope and frequency of a problem. It could seek a recall. Ford says it's cooperating with the probe. Shares of Ford Motor Co. rose 6 cents to $14.65 in morning trading Monday. Its shares are down 14 percent over the past year. Related Gallery Our Favorite Hot And Sporty Cars For 2015 Recalls Ford Lincoln NHTSA Ford Motor Company power steering mercury milan investigation

J Mays on the 2015 Ford Mustang

J Mays, head of design at Ford, may be retiring from the company after 16 years, but not before showing the world his swan song: the 2015 Mustang. Ford officially revealed its new coupe and convertible to the public at events around the world on Thursday, including a live unveiling on ABC's Good Morning America, and Mays was in attendance at the automaker's home event in Dearborn, MI, which is where we caught up with him for a few words about his new baby.
"It's a joy" to design the Mustang, Mays told Autoblog, adding that this sixth-generation coupe is his "favorite design so far." Of course, the 2015 model takes cues from all of the generations that came before it, but Mays said it was important to edit down the specific elements from previous models, leaving just enough off to let the customer "participate and fill in the blanks."
"If it doesn't sell itself, you probably aren't a Mustang fan."

A cool boost to turbocharger performance

Since the advent of the forced-induction engine, we have been looking for ways to get every drop of performance we can. There are many approaches to getting additional power using better intercooling, water injection, or even adding nitrous oxide. One take on a short instant burst of power is being researched by Mahle and involves providing supercooled air to an engine, which allows it to burn a leaner fuel mixture and produce more power. The supercooling idea is not new and was examined by Ford in 1993 on the Mustang Mach III concept car, then brought up again in 2003 with the SVT F-150 Lightning concept. Ford called its system the SuperCooler; it was designed to work with any turbocharged or supercharged engine equipped with a water-to-air intercooler. The system on the Lightning concept used a small tank of antifreeze that was hooked up to the truck air conditioning compressor. The air conditioning compressor cooled the antifreeze down to about 30 degrees. The other side of the tank was hooked up to the air-to-water intercooler, which usually had a temperature over 100 degrees. Once the antifreeze was circulated from the tank into the intercooler, it would lower the intercooler temperature and provide for a cooler, denser air charge into the engine; the result was around 50 extra horsepower for a burst of about 30 seconds to a minute, depending on the size of the tank. The system for the Lightning was to be offered as a $750 option and would have been targeted towards drag racers and the like, as it could be used for a run down the drag strip and then re-cooled by the time the truck was back in line. The system was fairly non-intrusive – it only weighed about 25 pounds and did not require a new compressor or intercooler. But as with many concepts, it was ultimately scrapped. The technology was always stuck in the back of my mind, but with larger and more powerful engines being produced it could not find its place. With the advent of new fuel economy standards, we have seen small-displacement turbocharged engines pop up and they seem like the perfect candidate for this type of technology. Ford's EcoBoost 1.0-liter three-cylinder turbocharged engine, as used in the Fiesta and Focus, is one such candidate for this technology. It would add a negligent amount of weight but could provide a boost of 10 to 20 horsepower when needed, like merging onto the highway or catching up to traffic.