1996 Chrysler Concorde Lx Sedan 4-door 3.3l on 2040-cars

Auto blog

Chrysler extends fuel tank warranties on LX cars, NHTSA ends probe

The National Highway Traffic Safety Administration has ended its investigation of 153,817, 5.7-liter and 6.1-liter Hemi V8-powered 2006 Chrysler 300, Dodge Charger and Dodge Magnum models after reports of stalling. Chrysler has responded by granting a lifetime warranty on the fuel tanks for these vehicles.
NHTSA received 299 reports of engines stalling while the models were stopped or driving at low speeds, and began an investigation. The government agency found that the control valve shutoff float in the V8s' 19-gallon fuel tank could malfunction if the fuel had too high of an ethanol content. In many cases, the valve would break in the open position, allowing the tank to be overfilled, which would then cause the cars to stall. However, there were no accidents reported, and the vehicles could be restarted immediately.
There will not be a recall on these vehicles because, "the condition represents a low risk to motor vehicle safety and is adequately addressed by Chrysler's extended warranty," NHTSA said to The Detroit News.

Chrysler 200 replacement coming in January

Autoweek reports the next Chrysler 200 will bow early next year. CEO Sergio Marchionne has said the 2015 model will debut next January, and Chrysler plans to cut the 2014 200 model year short to make way for the model's successor. According to AW, internal documents reveal 2014 model production will start this July and run through early January, 2014. The memos don't specify whether its Dodge Avenger twin will also see a shortened model year (the latter was originally rumored for discontinuation, but a successor is apparently back on the table). Chrysler is investing some $1 billion to construct paint and body facilities at its Sterling Heights, Michigan plant for the next-generation 200.
From what we've heard so far, we can expect the 2015 200 to bring a new design language to the Chrysler brand that will eventually bleed into the automaker's other products. Early reports have also suggested the four door will boast a nine-speed automatic transmission and return up to 38 miles per gallon.
Chrysler executed a very successful facelift in 2011, turning the flailing Sebring into the newly minted 200. Buyers responded enthusiastically, with sales jumping 44 percent in 2012. That step up was enough to make the 200 the brand's best-selling car. The momentum hasn't slackened, either, with sales up 21 percent during the first two months of this year.

NHTSA investigating power modules on Chrysler Group SUVs and minivans

The Center for Auto Safety is officially petitioning the National Highway Traffic Safety Administration to begin scrutinizing alleged problems with the totally integrated power module (TIPM) on about 24 Chrysler Group SUVs and minivans. The advocacy group claims that the part's failure can cause affected vehicles to stall or not start at all. NHTSA is still looking into the accusations and deciding whether a full investigation is actually warranted.
The CAS petition claims at least 70 TIPM failures, but according to NHTSA, six of the complaints are for models that don't have the modules. In 34 of the reported cases, the vehicles refused to start, and in 17 of them the engine stalled. There were also two allegations of smoke and one of a fire. However, none of these affected airbag deployment or resulted in a crash.
This petition isn't the first TIPM-related problem for Chrysler Group. A recent report in the New York Times alleged that it found 240 complaints potentially related to the issue on NHTSA's website alone. In September, the automaker also recalled 230,760 examples worldwide (188,723 in the US) of the 2011 Jeep Grand Cherokee and Dodge Durango replace the fuel pump relay circuit inside of the TIPM-7 with one external to the unit. The original part could allegedly cause the models to stall without warning. Even earlier, the company also recalled about 80,000 examples of the Jeep Wrangler and Dodge Nitro in 2007 to have the module reprogrammed.