Rebuildable/repairable Hail Damage 4x4 No Reserve on 2040-cars

Auto blog

Recharge Wrap-up: Renault Zoe recall, Proterra buses log 2M miles

Renault is recalling 10,649 examples of its Zoe electric car for potential brake hose failure. Cars built at the company's Flins factory between the Zoe's 2012 introduction and October 6, 2014 - a quarter of all Zoes ever built - are subject to the recall, though no accidents have been reported from rupturing brake lines. Recalled vehicles will have the brake hose positions inspected and, if need be, fixed. Read more from Reuters. Proposed legislation in Massachusetts would make the state even more EV friendly. While the state already encourages EV adoption with a $2,500 rebate incentive, the new bill would give battery electric vehicle drivers HOV lane access. Additionally it would set up a standard building code for EV chargers, and allow EV-only parking spaces. "With decreased gas prices, a 10 percent increase in vehicle miles traveled over the last 20 years, and a carpool rate below the national average, we must address personal vehicle use directly as part of our transportation emissions reduction strategy," says Rep. Frank Smizik. Read more from Teslarati. The New York Daily News has named the 2016 Chevrolet Volt as its "Green Machine of the Year." Seamless operation, peppiness, and a nice suite of equipment make it a top choice for the publication. "The 2016 Chevrolet Volt is all new, inside and out, and takes the plug-in hybrid segment to another level, thanks to its increased EV range, updated cabin, and more efficient gas-powered engine," writes Daily News Autos writer (and all-around good guy) Nick Kurczewski. Honorable mentions go to the Tesla Model S, BMW i3, Toyota Prius, and the hydrogen-powered Toyota Mirai. Read more from the Daily News, or at Clean Technica. Proterra electric buses have accumulated 2 million miles of revenue service. That equals 3,800 tons of carbon emissions that have been prevented and 420,000 gallons of fuel unburned. Proterra says it has 63 buses in service in 15 cities, and that it is ramping up production to meet growing demand. "This latest milestone exemplifies the economic, environmental and civic value of electric mass transit," says Proterra CEO Ryan Popple, "and demonstrates to the transit agencies that diesel - often viewed as a necessary evil - is no longer necessary." Read more at Inside EVs. Evercar, a unique EV carsharing service, has found success in Los Angeles. Evercar bills itself as carsharing for rideshare and delivery drivers.

GM recalls 8,500 Chevrolet Malibu models for rear suspension glitch

According to a letter from General Motors to the National Highway Traffic Safety Administration, flaws in the build process of the 2013 Chevrolet Malibu have led to the recall of 8,519 cars. Units built between December 6, 2011 and January 15, 2013 may have been assembled with rear suspension cradles that had insufficient torque applied to certain bolts. That out-of-spec assembly could lead to issues ranging from slight noises to a loss of vehicle control.
The problem was first noticed in December of last year by a GM test fleet driver and eventually tracked back to the improperly torqued bolts on the suspension cradle assembled through July 2012 by a supplier located not too far from the Malibu's Detroit/Hamtramck Assembly Plant. Since an official NHTSA recall notice has not been issued yet, it isn't clear whether or not Detroit-built Malibus were the only ones affected (the 2013 Malibu is also built at GM's Fairfax Assembly Plant in Kansas City, Kansas). Dealers will fix the problem by inspecting vehicles for proper torque specs, retightening if not within specs and, in some cases, perform a rear-wheel alignment.

2016 Chevy Volt arrives with 50-mile EV range, 41 mpg [w/ video]

Let's start with the numbers. The 2016 Chevy Volt will have an all-electric range of 50 miles from a new, 18.4-kWh lithium battery. It will get 41 miles per gallon (combined) once the battery runs dry and have 102 MPGe. Oh, and it has five seats, sort of. To compare, today's four-seat 2015 Volt has a 38-mile range from a 17.1-kWh battery in a powertrain that offers 37 mpg and 98 MPGe. So, across the board, there are notable improvements. Now that that's out of the way, let's talk story. General Motors will unveil the new Volt at the Detroit Auto Show later today, but it's been talking about how this new version – the first major plug-in hybrid vehicle to get a serious redo in the modern era – was crafted with reams and reams of data from first-gen Volt customers. At a preview event for journalists last week, GM executive chief engineer Pam Fletcher told Autoblog that these owners "gave us the recipe" to make the second-gen model. At the top of the request list was more range (check), more "fun-to-drive" behavior (check?) and a smoother and quieter experience (we'll assume a check here, given that the new 1.5-liter four-cylinder – the first North American application of this new engine family – should offer more power with less noise than the previous 1.4-liter, four-cylinder powerplant). Other customer-driven changes in the new Volt include a different place to store the charging cable (in the side of the trunk instead of under the load floor) and a new brake system with improved blended regenerative braking feel as well as driver-selectable regen levels. The requested 50-mile range comes from a new, lighter battery that has increased capacity from fewer cells (192 vs. 288) and a simplified control architecture. Along with the new battery, the electric drive unit is a two-motor deal that is up to 12 percent more efficient and 100 pounds lighter, while also being "tremendously smaller," notes Fletcher. It offers 294 pound-feet of torque and a maximum 149 horsepower of "motoring power" delivered to the wheels. GM says it has worked hard to reduced the amount of rare earth materials in these motors, and one of them doesn't use any at all. The new powertrain offers improved acceleration times, as well. The 2016 Volt can go from 0 to 60 miles per hour in 8.4 seconds, a seven-percent improvement, while the 0-30 mph time has been improved by 19 percent, down to 2.6 seconds. The new Volt is more conventional looking, but certainly not completely ordinary.