4x4 Tow Ready Clean Exterior Interior With Rear Air And Huge Interior Space on 2040-cars

Auto blog

2015 Chevy Spark will have lighter, smaller battery

As General Motors gets ready to release the 2015 Chevy Spark EV, it is retooling the Brownstown Battery Assembly to build a new battery system for the chirpy little electric car. The new Spark will lose a few pounds and kWh from its lithium-ion pack, but it will keep all of it's performance specs. The current Spark EV uses a 21-kWh lithium-ion battery pack with bits made by A123 Systems (known as B456 Systems during bankruptcy). For the 2015 model, GM is going to build a 19-kWh battery system in-house that will use 192 LG Chem cells. Losing a bit of energy capacity means that the battery system for the 2015 Spark EV will be 86 pounds lighter but it will keep the EPA-rated 82-mile range and 119 MPGe. The 2015 Spark EV also keeps its $26,685 (plus destination) starting price from the 2014 model. The car will once again qualify for a federal tax credit of up to $7,500. LG Chem also supplies the cells for GM's other plug-in vehicles from its facility in Western Michigan. The Brownstown production line currently builds the battery packs for the Chevy Volt, the Opel Ampera and the Cadillac ELR. You can read our first drive of the 2014 Chevy Spark here. Brownstown Battery Assembly Expands Capabilities Will build battery system for 2015 Chevrolet Spark EV 2014-05-14 DETROIT – General Motors will bring all its electric vehicle battery building capabilities in-house with production of battery systems for the 2015 Chevrolet Spark EV at its battery assembly plant in Brownstown, Mich. "Using our in-house engineering and manufacturing expertise enabled us to deliver a battery system that is more efficient and lighter than the 2014 Spark EV without sacrificing range," said Larry Nitz, executive director of GM global transmission and electrification engineering. "Our successful working relationship with LG Chem has allowed us to deliver a new battery system for the Spark EV that helps us to better leverage our economies of scale." A newly designed battery system features an overall storage capacity of 19 kWh and uses 192 lithium ion cells. The cells are produced at LG Chem's plant in Holland, Mich. The battery system weight of 474 lbs. is 86 pounds lighter than the system in the 2014 Spark EV. The Spark EV battery is built on a dedicated production line at Brownstown, which also manufactures complete battery packs for the Chevrolet Volt, Opel Ampera and Cadillac ELR.

2016 Chevy Volt arrives with 50-mile EV range, 41 mpg [w/ video]

Let's start with the numbers. The 2016 Chevy Volt will have an all-electric range of 50 miles from a new, 18.4-kWh lithium battery. It will get 41 miles per gallon (combined) once the battery runs dry and have 102 MPGe. Oh, and it has five seats, sort of. To compare, today's four-seat 2015 Volt has a 38-mile range from a 17.1-kWh battery in a powertrain that offers 37 mpg and 98 MPGe. So, across the board, there are notable improvements. Now that that's out of the way, let's talk story. General Motors will unveil the new Volt at the Detroit Auto Show later today, but it's been talking about how this new version – the first major plug-in hybrid vehicle to get a serious redo in the modern era – was crafted with reams and reams of data from first-gen Volt customers. At a preview event for journalists last week, GM executive chief engineer Pam Fletcher told Autoblog that these owners "gave us the recipe" to make the second-gen model. At the top of the request list was more range (check), more "fun-to-drive" behavior (check?) and a smoother and quieter experience (we'll assume a check here, given that the new 1.5-liter four-cylinder – the first North American application of this new engine family – should offer more power with less noise than the previous 1.4-liter, four-cylinder powerplant). Other customer-driven changes in the new Volt include a different place to store the charging cable (in the side of the trunk instead of under the load floor) and a new brake system with improved blended regenerative braking feel as well as driver-selectable regen levels. The requested 50-mile range comes from a new, lighter battery that has increased capacity from fewer cells (192 vs. 288) and a simplified control architecture. Along with the new battery, the electric drive unit is a two-motor deal that is up to 12 percent more efficient and 100 pounds lighter, while also being "tremendously smaller," notes Fletcher. It offers 294 pound-feet of torque and a maximum 149 horsepower of "motoring power" delivered to the wheels. GM says it has worked hard to reduced the amount of rare earth materials in these motors, and one of them doesn't use any at all. The new powertrain offers improved acceleration times, as well. The 2016 Volt can go from 0 to 60 miles per hour in 8.4 seconds, a seven-percent improvement, while the 0-30 mph time has been improved by 19 percent, down to 2.6 seconds. The new Volt is more conventional looking, but certainly not completely ordinary.

Recharge Wrap-up: Tesla sells Model S 85 and 70D in Malaysia, Chevy Spark EV built using clean energy

Tesla will send Model S 70D and Model S 85 EVs to Malaysia for leasing to government-linked companies. Only those companies will have access to the models as a two-year lease, which will be imported and leased by Malaysian Green Technology Corporation. The plan is part of an initiative by the Ministry of Energy, Green Technology and Water to allow government officials and other influential people to get to know the electric vehicles and the benefits that come along with them. Most of the 120 vehicles available will be the 70D model, and the lessee companies will have the option to purchase the cars at the end of the two years. Read more from Paul Tan's Automotive News. Wanxiang is hosting students from Delaware in China as part of a program to learn Mandarin and visit schools and science and technology sites. Wanxiang, the auto parts company that acquired Fisker (which had manufacturing based in Delaware) and battery maker A123 Systems, will give the students tours of its solar technology facilities, among other places, and see what daily life is like for families in the region. The program helps students interested in science and technology to foster marketable skills — like learning a foreign language — that will help them get jobs in industries around the world. Read more at Delaware Online. The Chevrolet Spark EV's electric motor (pictured) and drive unit are manufactured using clean energy. The e-motors building of the General Motors Baltimore Operations complex has a new rooftop solar array and uses LED and CFL lighting, helping the building recently earn LEED Silver certification. The landfill-free facility also takes advantage of the 1.23-megawatt solar array on the grounds, helping it source six percent its energy from renewable sources. The plant has reduced its energy intensity by 15.5 percent in three years, and continues to work toward reducing consumption and sourcing clean energy. "We believe reducing our environmental footprint is good for the climate and good for our business," says GM Executive Director of Global Public Policy Greg Martin. Read more in the press release below. Spark EV Motor Plant Fueled by Green, Clean Energy ENERGY STAR®, USGBC and Maryland state agency recognize facility's efforts WHITE MARSH, Md. – Chevrolet recently began selling the Spark EV to Maryland commuters able to take advantage of the state's robust charging infrastructure.