1951 Chevrolet Suburban Frame Off Restore on 2040-cars

Auto blog

New Takata problem results in recall of 414 GM vehicles

An airbag-inflator rupture discovered by Takata during testing has resulted in a new recall affecting 414 vehicles from General Motors, including 395 of them in the US. This latest campaign covers 2015 model-year examples of the Buick LaCrosse, Cadillac XTS, Chevrolet Camaro, Equinox, Malibu, and GMC Terrain. There are no reported breaks in any of these vehicles on the road, and the company estimates only one percent of them actually have the faulty parts. According to documents submitted to the National Highway Traffic Safety Administration (as a PDF), one side-airbag inflator failed a cold test at -40 Fahrenheit "releasing high pressure gas and propelling the separated components apart." The supplier told GM about the failure the next day. In these vehicles, the safety device might not only burst but the bag could inflate incorrectly, as well. GM and Takata say that a cause is not yet known, but they are "conducting an investigation." GM will begin notifying affected owners via overnight mail on Oct. 19. Dealers will replace the side airbag modules on all of the affected vehicles with new components outside of the suspect lot. All of the removed parts will also be collected for further study. Takata's faulty front airbag inflators have resulted in a serious scandal for the supplier. Initial figures indicated 34 million US vehicles are need of repair, though more recent figures have knocked that down to 23.4 million bad parts in 19.2 million automobiles. GM was already among the dozen automakers with models to fix, and some of its pickups were affected, along with the Saab 9-2X and Pontiac Vibe. GM Statement: General Motors is recalling 395 cars and crossovers in the U.S. because one of the front seat side air bags inflators may be defective. In the event of a deployment, the air bag's inflator may rupture and the air bag may not properly inflate. The rupture could cause metal fragments to strike the vehicle occupants, potentially resulting in serious injury or death. GM is unaware of any incidents involving vehicles with these components, which were part of a lot in which one inflator failed acceptance testing at the supplier. Dealers will replace the side air bag module or modules in affected vehicles. Including Canada, Mexico and exports, the total population of the recall is 414, GM estimates 1 percent of the recalled vehicles may have the defect.

Vert-A-Pac train cars kept your Chevy Vega's price in check

Our apologies to those who've seen this before, but for the rest of the class, how awesome are these pictures of the Vert-A-Pac shipping system General Motors came up with to ship the Chevrolet Vega back in the 1970s? Developed along with Southern Pacific Railroad, GM was able to double the amount of Vega models it could ship by packing them into the unique storage cars vertically.
At the time, rail cars could fit 15 vehicles each, but Chevrolet was able to lower shipping costs by making it possible to ship 30 Vegas per rail car, in turn allowing the price of the Vega to remain as low as possible. Each rail car had 30 doors that would fold down so that a Vega could be strapped on, and then a forklift would come along and lift the door into place. All the cars were positioned nose down, and since they were shipped with all of their required fluids, certain aspects had to be designed specifically for this type of shipping, including an oil baffle in the engine, a special battery and even a repositioned windshield washer reservoir. See for yourself in our image gallery above.

Recharge Wrap-up: Renault Zoe recall, Proterra buses log 2M miles

Renault is recalling 10,649 examples of its Zoe electric car for potential brake hose failure. Cars built at the company's Flins factory between the Zoe's 2012 introduction and October 6, 2014 - a quarter of all Zoes ever built - are subject to the recall, though no accidents have been reported from rupturing brake lines. Recalled vehicles will have the brake hose positions inspected and, if need be, fixed. Read more from Reuters. Proposed legislation in Massachusetts would make the state even more EV friendly. While the state already encourages EV adoption with a $2,500 rebate incentive, the new bill would give battery electric vehicle drivers HOV lane access. Additionally it would set up a standard building code for EV chargers, and allow EV-only parking spaces. "With decreased gas prices, a 10 percent increase in vehicle miles traveled over the last 20 years, and a carpool rate below the national average, we must address personal vehicle use directly as part of our transportation emissions reduction strategy," says Rep. Frank Smizik. Read more from Teslarati. The New York Daily News has named the 2016 Chevrolet Volt as its "Green Machine of the Year." Seamless operation, peppiness, and a nice suite of equipment make it a top choice for the publication. "The 2016 Chevrolet Volt is all new, inside and out, and takes the plug-in hybrid segment to another level, thanks to its increased EV range, updated cabin, and more efficient gas-powered engine," writes Daily News Autos writer (and all-around good guy) Nick Kurczewski. Honorable mentions go to the Tesla Model S, BMW i3, Toyota Prius, and the hydrogen-powered Toyota Mirai. Read more from the Daily News, or at Clean Technica. Proterra electric buses have accumulated 2 million miles of revenue service. That equals 3,800 tons of carbon emissions that have been prevented and 420,000 gallons of fuel unburned. Proterra says it has 63 buses in service in 15 cities, and that it is ramping up production to meet growing demand. "This latest milestone exemplifies the economic, environmental and civic value of electric mass transit," says Proterra CEO Ryan Popple, "and demonstrates to the transit agencies that diesel - often viewed as a necessary evil - is no longer necessary." Read more at Inside EVs. Evercar, a unique EV carsharing service, has found success in Los Angeles. Evercar bills itself as carsharing for rideshare and delivery drivers.