No Reserve Very Clean Utility Reading Truck Full Detailed Wholesale on 2040-cars

Auto blog

GM executive chief EV engineer says reducing cost of plug-in vehicles is 'huge priority'

As we know, another major automaker investing heavily in electrified vehicles is General Motors, and it's doing things much differently than rivals BMW, Ford or Nissan. The Chevrolet Volt extended-range EV is a modest seller at its $35,000 sticker price but a huge hit with owners. The Chevy Spark BEV, still in limited availability, puts smiley faces on its owners and drivers. The just-introduced Cadillac ELR, a sharp-looking, fun-driving $76,000 luxocoupe take on the Volt's EREV mechanicals, has admittedly low sales expectations. With this interesting trio in showrooms and much more in the works, the third vehicle electrification leader I collared for an interview at Detroit's North American International Auto Show (see #1 and #2) was Pam Fletcher, GM's executive chief engineer, Electrified Vehicles. ABG: Why do your EREVs need four-cylinder power to extend their range when BMW's i3 makes do with an optional 650 cc two-banger? "We designed [the Volt and the ELR] to go anywhere, any time" - Pam Fletcher PF: I get that question all the time: why not something smaller? You don't really need that much. You use the electric to its ability, then you just need to limp. But we designed those cars to go anywhere, any time, and we don't want their performance to be compromised. If you're driving through the mountains, we don't want you to be crawling up grades, or to be limited on any terrain. So it's optimized to be able to travel literally the biggest grades and mountain roads around the globe at posted speeds. Because what if you can't? Another good reason: when the engine is on, you have to run it wide open throttle, max speed, most of the time. And while we can do a lot with acoustics, and the ELR has active noise cancelation, a small-displacement, low cylinder-count engine at high speed, high load all the time isn't something you want to live with. That's how we came up with the balance we did among the key factors of performance, NVH [noise, vibration and harshness] and range. ABG: Where you go from here? Is the range-extender engine due for an update? PF: We know and love the current Volt, and there is still a lot of acclaim about it, so we think it's a good recipe. But we are heavily in the midst of engineering the next-generation car, which I think everyone will love and be excited about.

Plug In 2014: VIA makes the case for 'free' plug-in hybrid work vans, trucks

If you're a fleet manager who's been waiting anxiously for the chance to buy a plug-in hybrid van from Via Motors, your wait is almost over. If you work for the right fleet, anyway. David West, the chief marketing efficer for VIA Motors, took AutoblogGreen for a ride around the San Jose Convention Center in a Via van sporting an Electric Blue paint job as part of the Plug In 2014 Conference this week and gave us an update on how things are coming along. The big news is that the Via PHEV van production is going to start by the end of September. Via can currently build two vans an hour at its production plant in Mexico, or about 16 a day and could easily double that. "That would get us to 20,000 a year with two full lines running," West said. "We have the capacity." "There is no way gas can compete with electric." – David West, Via Motors But they can't sell that many quite yet. By the end of December, around 350 Vans will be made, mostly for a $20-million program from the Department of Energy (DOE) and the South Coast Air Quality Management District that will see the vehicles used by fleets that will report energy data to the Idaho National Lab. Via is also finishing up CARB certification for both the van and the company's plug-in hybrid pick-up truck. About 50 percent of Via's technology in the truck will not need to be tested again, since it's the same as what's in the van, but things like crash tests will need to be done twice. Despite the progress, this is not where Via hoped it would be today. The bankruptcy of battery supplier A123, "took about a year off our timeline," West said. "It's been getting a little slow getting it to market, there have been some challenges, particuarly since we had the country's worst recession right in the middle of this wrap up, but it's inevitable in my mind. There is no way gas can compete with electric." Maybe that's why FedEx has expressed an interest in buying around 5,000 units, West said. FedEx already has some pilot vehicles, just like Verizon does, and PG&E wants to replace all of their gas trucks with electric vehicles, which would be another 3,000 sales, he said. Besides the fuel savings, vehicles like these, with easy on-site power generation, could also work wonders in post-disaster situations, he said, since they could replace the need for generators.

Cadillac CT6 production ceases January 2020 as part of D-Ham layoffs

General Motors filed paperwork under the Worker Adjustment and Retraining Notification Act with Michigan's Department of Labor and Economic Opportunity this week, detailing events to come at the automaker's Detroit-Hamtramck Assembly Plant. Starting February 28, 814 salaried and hourly workers at D-Ham, as its called, will be laid off. The 753 workers represented by the UAW will begin receiving offers in January to relocate to facilities in Michigan and Ohio, or buyout offers. As the 4-million-square-foot plant winds down through April 3 to a skeleton crew, the Cadillac CT6 ceases production in January 2020, and the last Chevrolet Impala comes off the line on February 28. The loss of the CT6 represents the end of Cadillac's latest brief, and highly regarded, adventure into flagship sedans. It might also mean the end of the 4.2-liter Blackwing twin-turbo V8 engine, at least for the moment. Both casualties are calamities. The death of the Impala closes the door on a nameplate in production for 52 years since 1957, having started off as a top-tier trim for the 1958 Bel Air known as the Bel Air Impala, once advertised with the line, "Lets you know you're the boss." As part of the new four-year labor agreement with the UAW, GM is keeping D-Ham open to build a new line of battery-electric vehicles, ultimately investing $3 billion and tripling employment to 2,225 workers when fully operational. The agreement described the coming EV as a "van" that would commence production in late 2021, but various reports say what's actually coming is a range of premium EVs in pickup and SUV bodystyles under the program codename BT1. The easy predictions put an electric GMC Sierra and Cadillac Escalade among the EV fold, but not until 2023, according to auto industry forecaster LMC Automotive. Before that, LMC claims an electric van will debut in late 2021, along with a battery-powered rebirth of the Hummer brand in pickup and SUV forms, also in late 2021.