1966 Ss Nova L-79 4 Speed Number Matching With 16,000 Miles. on 2040-cars

Auto blog

New Takata problem results in recall of 414 GM vehicles

An airbag-inflator rupture discovered by Takata during testing has resulted in a new recall affecting 414 vehicles from General Motors, including 395 of them in the US. This latest campaign covers 2015 model-year examples of the Buick LaCrosse, Cadillac XTS, Chevrolet Camaro, Equinox, Malibu, and GMC Terrain. There are no reported breaks in any of these vehicles on the road, and the company estimates only one percent of them actually have the faulty parts. According to documents submitted to the National Highway Traffic Safety Administration (as a PDF), one side-airbag inflator failed a cold test at -40 Fahrenheit "releasing high pressure gas and propelling the separated components apart." The supplier told GM about the failure the next day. In these vehicles, the safety device might not only burst but the bag could inflate incorrectly, as well. GM and Takata say that a cause is not yet known, but they are "conducting an investigation." GM will begin notifying affected owners via overnight mail on Oct. 19. Dealers will replace the side airbag modules on all of the affected vehicles with new components outside of the suspect lot. All of the removed parts will also be collected for further study. Takata's faulty front airbag inflators have resulted in a serious scandal for the supplier. Initial figures indicated 34 million US vehicles are need of repair, though more recent figures have knocked that down to 23.4 million bad parts in 19.2 million automobiles. GM was already among the dozen automakers with models to fix, and some of its pickups were affected, along with the Saab 9-2X and Pontiac Vibe. GM Statement: General Motors is recalling 395 cars and crossovers in the U.S. because one of the front seat side air bags inflators may be defective. In the event of a deployment, the air bag's inflator may rupture and the air bag may not properly inflate. The rupture could cause metal fragments to strike the vehicle occupants, potentially resulting in serious injury or death. GM is unaware of any incidents involving vehicles with these components, which were part of a lot in which one inflator failed acceptance testing at the supplier. Dealers will replace the side air bag module or modules in affected vehicles. Including Canada, Mexico and exports, the total population of the recall is 414, GM estimates 1 percent of the recalled vehicles may have the defect.

Next-gen Chevy Silverado and GMC Sierra may use carbon fiber

It's been generally accepted that the next generation of full-size GM trucks will use some sort of strong, lightweight material for the beds while retaining steel for the cab. While aluminum seems like the most obvious choice, according to Automotive News, the Chevy Silverado and GMC Sierra will incorporate both aluminum and carbon fiber in their beds. The publication cites sources from within GM, though it seems the introduction of this comparatively exotic material mix is still a few years off. While carbon fiber is both stronger and lighter than steel and aluminum, it takes significantly more time and money to produce, essentially relegating the material to small-volume cars. The main benefit for trucks is the resulting reduction in weight to improve fuel economy without sacrificing the tough, rugged capabilities truck buyers expect. The Ford F-150 made the switch to aluminum for the 2015 model year and it's proved highly successful. It seemed like it was only a matter of time before the competition followed suit. Automotive News says that the next-gen trucks will launch with aluminum beds and that it will take a couple of years before we'll see any carbon fiber incorporated into the design. Even then, only look for the composite material on higher-trim models, with a trickle down to lower-spec trucks possible further in the future. In 2011, GM announced it was working with Japan-based Teijin Limited on a carbon fiber reinforced thermoplastic. There's a good chance that material's introduction will be on trucks. Related Video: News Source: Automotive News Plants/Manufacturing Rumormill Chevrolet GM GMC Truck

Recharge Wrap-up: Tesla sells Model S 85 and 70D in Malaysia, Chevy Spark EV built using clean energy

Tesla will send Model S 70D and Model S 85 EVs to Malaysia for leasing to government-linked companies. Only those companies will have access to the models as a two-year lease, which will be imported and leased by Malaysian Green Technology Corporation. The plan is part of an initiative by the Ministry of Energy, Green Technology and Water to allow government officials and other influential people to get to know the electric vehicles and the benefits that come along with them. Most of the 120 vehicles available will be the 70D model, and the lessee companies will have the option to purchase the cars at the end of the two years. Read more from Paul Tan's Automotive News. Wanxiang is hosting students from Delaware in China as part of a program to learn Mandarin and visit schools and science and technology sites. Wanxiang, the auto parts company that acquired Fisker (which had manufacturing based in Delaware) and battery maker A123 Systems, will give the students tours of its solar technology facilities, among other places, and see what daily life is like for families in the region. The program helps students interested in science and technology to foster marketable skills — like learning a foreign language — that will help them get jobs in industries around the world. Read more at Delaware Online. The Chevrolet Spark EV's electric motor (pictured) and drive unit are manufactured using clean energy. The e-motors building of the General Motors Baltimore Operations complex has a new rooftop solar array and uses LED and CFL lighting, helping the building recently earn LEED Silver certification. The landfill-free facility also takes advantage of the 1.23-megawatt solar array on the grounds, helping it source six percent its energy from renewable sources. The plant has reduced its energy intensity by 15.5 percent in three years, and continues to work toward reducing consumption and sourcing clean energy. "We believe reducing our environmental footprint is good for the climate and good for our business," says GM Executive Director of Global Public Policy Greg Martin. Read more in the press release below. Spark EV Motor Plant Fueled by Green, Clean Energy ENERGY STAR®, USGBC and Maryland state agency recognize facility's efforts WHITE MARSH, Md. – Chevrolet recently began selling the Spark EV to Maryland commuters able to take advantage of the state's robust charging infrastructure.