2014 Chevrolet Malibu 3lt on 2040-cars

Auto blog

2016 Chevy Volt arrives with 50-mile EV range, 41 mpg [w/ video]

Let's start with the numbers. The 2016 Chevy Volt will have an all-electric range of 50 miles from a new, 18.4-kWh lithium battery. It will get 41 miles per gallon (combined) once the battery runs dry and have 102 MPGe. Oh, and it has five seats, sort of. To compare, today's four-seat 2015 Volt has a 38-mile range from a 17.1-kWh battery in a powertrain that offers 37 mpg and 98 MPGe. So, across the board, there are notable improvements. Now that that's out of the way, let's talk story. General Motors will unveil the new Volt at the Detroit Auto Show later today, but it's been talking about how this new version – the first major plug-in hybrid vehicle to get a serious redo in the modern era – was crafted with reams and reams of data from first-gen Volt customers. At a preview event for journalists last week, GM executive chief engineer Pam Fletcher told Autoblog that these owners "gave us the recipe" to make the second-gen model. At the top of the request list was more range (check), more "fun-to-drive" behavior (check?) and a smoother and quieter experience (we'll assume a check here, given that the new 1.5-liter four-cylinder – the first North American application of this new engine family – should offer more power with less noise than the previous 1.4-liter, four-cylinder powerplant). Other customer-driven changes in the new Volt include a different place to store the charging cable (in the side of the trunk instead of under the load floor) and a new brake system with improved blended regenerative braking feel as well as driver-selectable regen levels. The requested 50-mile range comes from a new, lighter battery that has increased capacity from fewer cells (192 vs. 288) and a simplified control architecture. Along with the new battery, the electric drive unit is a two-motor deal that is up to 12 percent more efficient and 100 pounds lighter, while also being "tremendously smaller," notes Fletcher. It offers 294 pound-feet of torque and a maximum 149 horsepower of "motoring power" delivered to the wheels. GM says it has worked hard to reduced the amount of rare earth materials in these motors, and one of them doesn't use any at all. The new powertrain offers improved acceleration times, as well. The 2016 Volt can go from 0 to 60 miles per hour in 8.4 seconds, a seven-percent improvement, while the 0-30 mph time has been improved by 19 percent, down to 2.6 seconds. The new Volt is more conventional looking, but certainly not completely ordinary.

GM tells owners not to use SUV wipers due to fire risk

General Motors is recalling 31,685 examples of the 2016 Buick Enclave, Chevrolet Traverse, and GMC Acadia because a short circuit in the windshield wiper motor can potentially lead to a fire. Due to the danger, the company is asking owners not to use the wipers until the problem is fixed, according to The Detroit Free Press citing the Associated Press. A manufacturing defect in the wiper motor cover means that the electrical terminals can come into contact and cause a short. The part could "melt, smoke, or catch fire," according to a statement from GM. The company will get them fixed immediately, and dealers will replace the cover. If there's bad weather at the time the owner specifies to get the recall work completed, the automaker will come pick up the crossovers. Depending on parts availability, the automaker will supply a rental car for customers, as well. The issue was discovered at the factory. According to the company's statement, only 6,405 actually made it to customers, and they were notified immediately by overnight letter. The rest were in dealer stock. The affected crossovers carry build dates between August 18, 2015 and September 24, 2015. Of those, there are 29,295 in the US and 1,073 in Canada. GM Statement: General Motors has told the National Highway Traffic Safety Administration that it will recall approximately 29,295 2016 model year Chevrolet Traverse, Buick Enclave and GMC Acadia SUVs in the U.S. because the front windshield wiper motor may overheat when in use because of a manufacturing defect. In some cases, the front windshield wiper motor cover may melt, smoke or catch fire. The approximately 6,405 customers who have taken delivery of these vehicles were notified by overnight letter and are urged to contact a GM dealer as soon as possible to arrange a service appointment. These customers should not use the front windshield wipers until they have been repaired. If weather conditions prevent driving the vehicle without using the windshield wipers, GM will arrange to pick up the vehicle for servicing. If repair parts are unavailable, GM will provide a rental car at no cost until parts become available. The total population, including Canada, Mexico and exports, is approximately 31,685. About 25,280 of these vehicles are in dealer stock and will not be sold until repairs are made.

How real is the Chevy Bolt EV and will it really cost $30,000?

"This is us bragging that we can do this kind of car." That's how Michael Simcoe, GM's executive director for NA exteriors, described the Chevy Bolt EV concept, which made a surprise appearance at the Detroit Auto Show today. While there was talk of a 2017 production debut, this is for sure a concept vehicle. But that means the ideas behind the vehicle are perhaps more important than the details. For example, no one is talking about what size battery might appear in a production Bolt, but Simcoe would talk about how rapid progress in battery improvements made it possible for GM to make the bold Bolt declaration that promises 200 miles and a price tag of around $30,000 (after incentives). But if the Bolt makes it to market, it won't be until 2017 (as rumored) or later, is it really fair to promote the car as being available with a federal tax credit? For one thing, credits for plug-in vehicles may change in the next few years, but if the laws stay the same, each manufacturer is limited to 200,000 vehicles before the credits start to decline. GM is justifiably proud that it's sold over 70,000 Volts thus far, but with a new model coming out later this year and a few years to go until the Bolt potentially arrives, GM could be pushing right up against that 200,000 limit when the Bolt goes on sale. But Volt executive chief engineer Pam Fletcher told AutoblogGreen that, "We're just trying to take some of the confusion out." "Think about talking to the average consumer," she said. "First, going through the explanation of how the federal tax credit was set up, how it's being used and so on. [In the industry, we] have the luxury of understanding the nuances of that regulation, but right now people who aren't in the marketplace, they don't have the luxury of all that. It's already hard to communicate the details so we gave them data in a way that is what they're used to seeing." There was one question that drove the two-year Bolt gestation and design period, Simcoe said: What does a better battery offer a vehicle designer? "We've got a number of spaces we play in for powertrain technology and obviously electrification is one of them," he said. "With Volt 1 and then the Spark EV, with that development and batteries getting better for us, we started doing some practical packaging to deliver a vehicle which was not the traditional aero form which you see around electric vehicles.