2014 Chevrolet Impala 2lz on 2040-cars

Auto blog

New Takata problem results in recall of 414 GM vehicles

An airbag-inflator rupture discovered by Takata during testing has resulted in a new recall affecting 414 vehicles from General Motors, including 395 of them in the US. This latest campaign covers 2015 model-year examples of the Buick LaCrosse, Cadillac XTS, Chevrolet Camaro, Equinox, Malibu, and GMC Terrain. There are no reported breaks in any of these vehicles on the road, and the company estimates only one percent of them actually have the faulty parts. According to documents submitted to the National Highway Traffic Safety Administration (as a PDF), one side-airbag inflator failed a cold test at -40 Fahrenheit "releasing high pressure gas and propelling the separated components apart." The supplier told GM about the failure the next day. In these vehicles, the safety device might not only burst but the bag could inflate incorrectly, as well. GM and Takata say that a cause is not yet known, but they are "conducting an investigation." GM will begin notifying affected owners via overnight mail on Oct. 19. Dealers will replace the side airbag modules on all of the affected vehicles with new components outside of the suspect lot. All of the removed parts will also be collected for further study. Takata's faulty front airbag inflators have resulted in a serious scandal for the supplier. Initial figures indicated 34 million US vehicles are need of repair, though more recent figures have knocked that down to 23.4 million bad parts in 19.2 million automobiles. GM was already among the dozen automakers with models to fix, and some of its pickups were affected, along with the Saab 9-2X and Pontiac Vibe. GM Statement: General Motors is recalling 395 cars and crossovers in the U.S. because one of the front seat side air bags inflators may be defective. In the event of a deployment, the air bag's inflator may rupture and the air bag may not properly inflate. The rupture could cause metal fragments to strike the vehicle occupants, potentially resulting in serious injury or death. GM is unaware of any incidents involving vehicles with these components, which were part of a lot in which one inflator failed acceptance testing at the supplier. Dealers will replace the side air bag module or modules in affected vehicles. Including Canada, Mexico and exports, the total population of the recall is 414, GM estimates 1 percent of the recalled vehicles may have the defect.

GM execs fired over fraudulent India emissions testing

General Motors hadn't had a recall in India since 1995. That changed when it was discovered that certain employees were playing tricks with local emissions testing in order to ensure passing grades for engines. More than ten GM Powertrain employees in India and the US have been let go over the ensuing emissions flap, including Sam Winegarden, VP of global engine engineering, a man who has been with the company since 1969, leading development of some marquee powerplants.
According to Automotive News, an internal investigation revealed that employees "violated testing procedures," sometimes swapping specially prepared low-emissions engines during testing regimes for the Chevrolet Tavera SUV equipped with the 2.0-liter and 2.5-liter engines. Employees were also manipulating weights in order to get vehicles placed into different emissions categories. The discovery has led to GM recall the 114,000 Taveras produced over an eight-year period and halting their production and sale.
The Economic Times of India reports that the issue is due to "a faulty component." GM has developed a solution to the issue, and once it is validated in testing and approved by the Indian authorities, the recalled vehicles will be fixed at dealers and production will resume.

Chevy Malibu Hybrid wins 2016 Connected Green Car of the Year

From the Washington Auto Show today, Green Car Journal's Ron Cogan announced three different fuel-efficient vehicle awards. They were: 2016 Connected Green Car of the Year: Chevy Malibu Hybrid 2016 Luxury Green Car of the Year: Volvo XC90 T8 2016 Green SUV of the Year: Honda HR-V The Volvo was nominated in two categories, but it did not win the Connected Green Car of the Year. Speaking of non-winners, the other green SUV finalists were the BMW X1 XDrive28i, Hyundai Tucson, Mazda CX-3, and Toyota RAV4 Hybrid. The other Luxury Green Car finalists included the BMW x5 xDrive40e, Lexus RX 450h, Porsche Cayenne S E-Hybrid, and the Mercedes-Benz C350e. Finally, the Audi A3 e-tron, BMW 330e, Toyota Prius, and Volvo XC90 T8 were the runners up for Connected Green Car. 2016 Connected Green Car of the Year, Green SUV of the Year, Luxury Green Car of the Year Winners Announced WASHINGTON, Jan. 21, 2016 /PRNewswire/ -- Green Car Journal has announced the winners of its prestigious 2016 Green Car Awards at a press conference held today during the Washington Auto Show's Public Policy Day in Washington DC. Distinguished as 2016 Luxury Green Car of the Year™ is Volvo's new XC90 T8. The Chevrolet Malibu Hybrid tops the field as 2016 Connected Green Car of the Year™ and Honda's HR-V earns Green Car Journal's 2016 Green SUV of the Year™. "These are stand-out vehicles in an increasingly sophisticated and appealing field of 'green' cars," said Ron Cogan, editor and publisher of Green Car Journal and CarsOfChange.com. "To make the cut as a finalist is a real achievement in itself considering the considerable competition in the market today. Rising to the top as award winners means these three exceptional vehicles set a benchmark in the auto industry's effort to create vehicles that are desirable and efficient, while also achieving environmental milestones so important for our driving future." The Green Car Awards are a key feature of The Washington Auto Show, the "public policy show" on the auto show circuit and one that puts a priority on safety and sustainability. "We are extremely proud of our partnership with Ron Cogan, whose eagerly anticipated suite of awards help shape the national conversation on the innovations that will drive our industry and country forward," said Geoff Pohanka, chairman of The Washington Auto Show.