2013 Chevrolet Equinox Lt on 2040-cars

Auto blog

GM patent reveals new two-stage turbocharger

Modern turbochargers may be some of the best ever made, but performance is something that engineers are always trying to improve. According to GM Inside News, General Motors (GM) is hoping to alleviate some of the negative aspects of a two-stage turbocharger setup with a newly-patented design. The patent, that was filed on May 19, 2016, reveals a clever bypass system that allows the engine, a four-cylinder unit, to optimize both the low-pressure and high-pressure inlets for its respective functions. According to the filing, a conventional two-stage turbocharger setup is engineered to allow both turbines to operate simultaneously at low and mid engine speeds. At high engine speeds, only the low-pressure turbine works. The setup can't isolate either the low or high pressure side, which can impair low-end performance. GM's new two-stage turbocharger setup looks to eliminate this by linking the high-pressure turbo to the exhaust manifold through the high-pressure inlet duct. The low-pressure turbo is attached to the high-pressure turbo by a low-pressure inlet duct, which is linked to a connecting channel. A single actuator that is housed in the exhaust manifold creates a bypass that can opens the high-pressure inlet or close the connecting channel. Depending on what the engine load and speed is, the ECU guides the actuator—a single rotating spindle with discs corresponding to flanges on the high and low pressure sides—to isolate one of the two turbos. Isolating the turbos allow the respective inlets to be engineered for the best possible fluid dynamic performance. The setup should increase performance and decrease lag. There's no word on what car this setup will make an appearance on, but it will most likely be used in premium vehicles before trickling down to the rest of GM's vehicles. Related Video: News Source: GM Inside News, AutoGuide via GM Authority Cadillac Chevrolet GM Technology Sedan turbo patent engine turbocharging

Chevy Volt owners log half a billion electric miles, 2015 production starts

As General Motors gets ready to start 2015 Volt production Monday, Chevrolet is looking back at some of the numbers that got the car to where it is today. The headline number is that Volt owners have collectively put more than a half-billion electric miles on their cars. The unsurprising upshot is that, if you went out and bought a Volt, you're pretty keen on getting as many electric miles out of it as possible. 90 percent of all Volt trips are done purely on electric power. The typical Volt driver goes 970 miles between fill-ups, GM says, and that means that 63 percent of all miles are done on battery power. General Motors executive director Larry Nitz gave AutoblogGreen a few more details on the usage habits of Volt drivers, including that 81 percent of commuting miles are electric. Two-thirds of US Volt drivers charge their vehicle 1.4 times a day, a clear indicator of drivers trying to maximize electric miles through opportunity charging. In fact, Nitz said, 90 percent of all Volt trips are done purely on electric power. GM also says that the Volt's official 35 miles of electric range is still doable for many owners who have had their car for more than 30 months. Looking ahead, we know that one upgrade for the 2015 Volt will be 4G LTE connectivity that can turn the car, like others in the GM family, into a mobile wifi hotspot. We're of course much more interested in when GM is finally going to start production of the next-gen Volt, but GM officials would only tell us that they're very excited about the still-secret vehicle, promising we'll be learning more "soon." Nitz did confirm that today's Volt drivers are most interested in three things from the next-gen model: more range, a lower price and a fifth seat. He did not say whether or not GM will be able to deliver on those requests. Chevrolet Volt Owners Surpass Half a Billion Electric Miles After 30 months of use, a sampling of Volts shows consistent all-electric range 2014-06-19 DETROIT – Since its launch in late 2010, Chevrolet Volt owners have accumulated more than half a billion all-electric miles. Additionally, based on a General Motors' study of more than 300 Volts in service in California for more than 30 months, many owners are exceeding the EPA-rated label of 35 miles of EV range per full charge, with about 15 percent surpassing 40 miles of range.

Recharge Wrap-up: Range-extended EV taxis in London, 2016 Chevy Volt interior two years old

The first Metrocab range-extended EV taxis are operating on the streets of London. The cabs use a 12.2-kWh battery and two 50-kW motors, as well as a 1.0-liter gasoline range extender. Fuel economy is 98 MPGe on the ECE101 cycle, and total driving range is over 348 miles before needing to charge or refuel. Cabbies can expect to save GBP20 to GBP40 (about $30 to $60) per day on average. "The cash savings on fuel are significant, the ride and comfort outstanding, and my first customers are thrilled with the new cab," says the first operator of the new EV taxi, Preston Morris. "With its air suspension providing unrivaled comfort, panoramic glass roof for views of the city and silent powertrain, what's not to like?" Read more in the press release below. Chevrolet has had the interior design of the 2016 Volt finished for two years already, according to GM interior designer John McDougall. Beginning around 2010, GM received sketches from designers worldwide before narrowing it down to a handful of designs. Then the top three choices were molded from clay. The chosen theme was then refined for up to 18 months. "Every little thing you can imagine goes into that," says McDougall. "The glare angle from the windows, the placement of the controls, the placement of the seat. You have to create something that's beautiful and functional." Read more at GM Authority and at Inside EVs. More details have emerged about the Second Life Batteries Alliance. Vattenfall has announced a research project in partnership with BMW and Bosch to use retired EV batteries for stationary, grid-connected energy storage in Hamburg, Germany. Over 100 lithium-ion batteries from BMW i3 and ActiveE vehicles will make up a two-mWh storage unit for grid balancing, enough to power 30 four-person households for a week. The system is "compact enough to fit in a small building," says Bosch. Such storage systems are especially fit for storing and moving alternative forms of energy, which often fluctuate in supply more than electricity from a traditional power plant. Vattenhall will operate the storage unit for 10 years, with Bosch managing the batteries, during which time the three partners hope to learn more about battery applications and their performance over time. Read more at Green Car Congress, or in the press release below.