4 Spd Trany, Engine Redone 500hp, Good Project Car on 2040-cars

Auto blog

GM recalls 8,500 Chevrolet Malibu models for rear suspension glitch

According to a letter from General Motors to the National Highway Traffic Safety Administration, flaws in the build process of the 2013 Chevrolet Malibu have led to the recall of 8,519 cars. Units built between December 6, 2011 and January 15, 2013 may have been assembled with rear suspension cradles that had insufficient torque applied to certain bolts. That out-of-spec assembly could lead to issues ranging from slight noises to a loss of vehicle control.
The problem was first noticed in December of last year by a GM test fleet driver and eventually tracked back to the improperly torqued bolts on the suspension cradle assembled through July 2012 by a supplier located not too far from the Malibu's Detroit/Hamtramck Assembly Plant. Since an official NHTSA recall notice has not been issued yet, it isn't clear whether or not Detroit-built Malibus were the only ones affected (the 2013 Malibu is also built at GM's Fairfax Assembly Plant in Kansas City, Kansas). Dealers will fix the problem by inspecting vehicles for proper torque specs, retightening if not within specs and, in some cases, perform a rear-wheel alignment.

The Jitterbugs somersaulted at the 1986 Chicago Auto Show for the Chevy Nova

Judging by the vintage videos that the Chicago Auto Show has been uploading, if you wanted to check out the latest vehicles and watch some dancers in the same place in the late '80s and early '90s, then the Windy City event was definitely the place to be. We've already seen the Footlockers pitching the Cavalier in '88 and a troupe of women singing about the Geo brand in '91. Apparently, the trend went back even further, though. Just take a look at this group called the Jitterbugs selling some badge-engineered products from Chevrolet at the 1986 show. Flanked by the Chevy Nova and Spectrum, these guys managed to do a few pretty impressive jumps and somersaults but mixed them with some rather uninspired spins, as well. Also, wait for 1:24 into the clip to see the least enthusiastic backup dancers that the world has ever known. The Jitterbugs are even further proof that Chevy's habit of mixing dancing and its vehicles goes back even further than the Volt. News Source: ChicagoAutoShow via YouTube Auto News Marketing/Advertising Chicago Auto Show Chevrolet Videos Chicago chevy nova

Some 2012-13 Chevy Volts may not have enough battery coolant

The 2012 and 2013 model year Chevrolet Volt extended-range plug-in vehicle may have a battery glitch caused by low coolant levels. No recall has been issued and General Motors is taking care of the issue at no cost to drivers. Some of the affected Volts may have lower-than-advisable coolant levels because of some pesky air pockets in the car's cooling circuit. When the coolant levels get too low, the charging system for the battery powering the car's onboard generator (i.e. the Rechargeable Energy Storage System, or the RESS) may be shut down, turning one's Volt into a run-of-the-mill gas-powered car, and a pricey one at that. The Car Connection says GM is advising owners of the '12 and '13 Volts to contact their local Chevy dealer for a free fix. GM representatives didn't immediately respond to a request for comment from AutoblogGreen for more details. We believe this is a separate issue than the one that brought 8,000 Volts back to the dealers for a battery coolant fix, what GM called a "voluntary customer satisfaction effort," a few years ago. General Motors sold 23,094 Chevy Volts last year after selling 23,461 Volts in 2012, so that fix-it list may get fairly lengthy. Check out a GM-Volt.com user thread related to this issue here. *UPDATE: Chevrolet spokesman Randy Fox confirmed in an e-mail to AutoblogGreen that the company issued a service bulletin to dealers that they may need to top off coolant levels on certain Volts because of the issue, and that the vehicle will "return to normal charging operation" once that's done.