Chevelle/ Malibu on 2040-cars

Auto blog

GM recalls 8,500 Chevrolet Malibu models for rear suspension glitch

According to a letter from General Motors to the National Highway Traffic Safety Administration, flaws in the build process of the 2013 Chevrolet Malibu have led to the recall of 8,519 cars. Units built between December 6, 2011 and January 15, 2013 may have been assembled with rear suspension cradles that had insufficient torque applied to certain bolts. That out-of-spec assembly could lead to issues ranging from slight noises to a loss of vehicle control.
The problem was first noticed in December of last year by a GM test fleet driver and eventually tracked back to the improperly torqued bolts on the suspension cradle assembled through July 2012 by a supplier located not too far from the Malibu's Detroit/Hamtramck Assembly Plant. Since an official NHTSA recall notice has not been issued yet, it isn't clear whether or not Detroit-built Malibus were the only ones affected (the 2013 Malibu is also built at GM's Fairfax Assembly Plant in Kansas City, Kansas). Dealers will fix the problem by inspecting vehicles for proper torque specs, retightening if not within specs and, in some cases, perform a rear-wheel alignment.

Autoblog Minute: VW finds CO2 'irregularities', Takata dropped by automakers, SEMA recap

Volkswagen's diesel emissions scandal gets a new wrinkle, US regulators hit Takata Corporation with a substantial fine, and we head to Las Vegas for a look at tuner paradise at the 2015 SEMA show. Autoblog senior editor Greg Migliore reports on this edition of Autoblog Minute Weekly Recap. Show full video transcript text [00:00:00] Volkswagen's diesel emissions scandal gets a new wrinkle. US regulators issue a significant fine to Takata Corporation. And we take a peek inside tuner paradise at the 2015 SEMA show. I'm senior editor Greg Migliore and this is your Autoblog Minute Weekly Recap. The VW diesel emissions scandal, first brought to light in September, gets a new wrinkle, as an internal investigation by the German automaker revealed [00:00:30] irregularities in CO2 emissions that could affect approximately 800,000 vehicles. VW estimates the issue could pose a 2-billion euro economic risk. VW claims that most of the vehicles affected have diesel engines, but industry analysts say a 1.4-liter gas engine is also affected. VW says that fuel consumption figures were set too low during the CO2 certification process. During all of this, sales of some diesel-powered Volkswagen, Audi, and Porsche models [00:01:00] have been halted. Takata Corporation is back in the news in connection with its deadly airbag scandal. Federal regulators fined Takata $70 million. If the parts supplier does not comply, the fine could balloon to $200 million. Takata was also dropped this week by its biggest customer, Honda. And now, Toyota and Mazda will be following Honda's lead in dropping Takata. We're also hearing that Mitsubishi and Subaru are considering a switch in air-bag inflator suppliers. SEMA 2015 [00:01:30] came and went. We saw offerings from Mopar, like the AWD Challenger concept. Honda unveiled a Ridgeline that it will race at the Baja 1000, which gives us a hint at what future production model could look like. The celebrity presence was also felt in Vegas as it always is. Kid Rock brought a Duramax Diesel Chevy Silverado, and Acura restored and presented Ludacris with his now famous 1993 Acura Legend. Those are the highlights from the week that was. Be sure to come back on Saturday for my full recap, [00:02:00] where I'll have some added insight into Hyundai's foray into the luxury sector. For Autoblog, I'm Greg Migliore. Autoblog Minute is a short-form video news series reporting on all things automotive.

Buick Encore, Chevy Trax earn Top Safety Pick from IIHS [w/video]

The Buick Encore has been a massive sales success practically from the moment it debuted, and Buick recently decided to increase production to keep up with demand for the premium compact crossover. The Insurance Institute for Highway Safety recently put one to the test again, and the Encore earned a Top Safety Pick award. It's the first model from the brand to score the nod since 2013, according to the IIHS, and the rating also carries over to the 2015 Chevrolet Trax. The 2015 Encore scored a Good rating in all of the IIHS' evaluations, including the 40-mile-per-hour, small overlap front crash test. That was a big improvement over the previous model the institute tested, which scored a Poor result in the overlap test. In the first test, about 13 inches of the lower door hinge pillar came into the passenger compartment, and the steering wheel airbag moved too far to protect the dummy's head. Improvements for the latest model year showed six inches of intrusion this time, and the airbags caught the dummy's head well. The dummy's sensors also indicated a low risk of injury. The two CUVs missed out on the full Top Safety Pick+ because the IIHS scored the Encore as only having a basic front crash prevention system, and there was no such equipment for the Trax. To earn the highest mark, models need at least an advanced rating by the institute for this technology. Buick Encore, Chevrolet Trax earn 2015 TOP SAFETY PICK award ARLINGTON, Va. - A small SUV is the first vehicle from the Buick brand to qualify for a TOP SAFETY PICK award from the Insurance Institute for Highway Safety since 2013. The Buick Encore's newly introduced, lower-priced twin, the Chevrolet Trax, also qualifies for the honor. The Encore's award follows improvements to the SUV's structure for better small overlap front protection. The 2015 model earns a good rating in the small overlap test. In contrast, the 2013-14 Encore rated poor in the test. The driver's space was seriously compromised with intrusion measuring as much as 13 inches at the lower door hinge pillar. The dummy's head barely contacted the front airbag before sliding off the left side, as the steering column moved to the right. The side curtain airbag deployed too late and didn't have sufficient forward coverage to protect the head. In the latest test, the driver space was maintained reasonably well, with maximum intrusion of 6 inches at the door hinge pillar and instrument panel. The dummy's movement was well-controlled.