1970 Chevrolet Chevelle on 2040-cars

Auto blog

New Takata problem results in recall of 414 GM vehicles

An airbag-inflator rupture discovered by Takata during testing has resulted in a new recall affecting 414 vehicles from General Motors, including 395 of them in the US. This latest campaign covers 2015 model-year examples of the Buick LaCrosse, Cadillac XTS, Chevrolet Camaro, Equinox, Malibu, and GMC Terrain. There are no reported breaks in any of these vehicles on the road, and the company estimates only one percent of them actually have the faulty parts. According to documents submitted to the National Highway Traffic Safety Administration (as a PDF), one side-airbag inflator failed a cold test at -40 Fahrenheit "releasing high pressure gas and propelling the separated components apart." The supplier told GM about the failure the next day. In these vehicles, the safety device might not only burst but the bag could inflate incorrectly, as well. GM and Takata say that a cause is not yet known, but they are "conducting an investigation." GM will begin notifying affected owners via overnight mail on Oct. 19. Dealers will replace the side airbag modules on all of the affected vehicles with new components outside of the suspect lot. All of the removed parts will also be collected for further study. Takata's faulty front airbag inflators have resulted in a serious scandal for the supplier. Initial figures indicated 34 million US vehicles are need of repair, though more recent figures have knocked that down to 23.4 million bad parts in 19.2 million automobiles. GM was already among the dozen automakers with models to fix, and some of its pickups were affected, along with the Saab 9-2X and Pontiac Vibe. GM Statement: General Motors is recalling 395 cars and crossovers in the U.S. because one of the front seat side air bags inflators may be defective. In the event of a deployment, the air bag's inflator may rupture and the air bag may not properly inflate. The rupture could cause metal fragments to strike the vehicle occupants, potentially resulting in serious injury or death. GM is unaware of any incidents involving vehicles with these components, which were part of a lot in which one inflator failed acceptance testing at the supplier. Dealers will replace the side air bag module or modules in affected vehicles. Including Canada, Mexico and exports, the total population of the recall is 414, GM estimates 1 percent of the recalled vehicles may have the defect.

Race Recap: Rolex 24 at Daytona was fast and feisty

Let the record show that victory at the 2015 Rolex 24 at Daytona went to the No. 02 Chip Ganassi Racing with Felix Sabates Target/Ford EcoBoost Riley DP driven by Verizon IndyCar drivers Scott Dixon and Tony Kanaan and NASCAR drivers Jamie McMurray and Kyle Larson. The winner did 740 laps to cover 2,634.3 miles in 24 hours and 57.667 seconds. That's a statement to this year's pace in spite of 18 cautions, two more than last year: the Michael Shank Racing Ligier got pole with a time of 1:39.194, slower than last year's pole time of 1:38.270; however, the winning car last year only did 695 laps. The fight for top honors was shaved to a four-car battle over the first third of the event. The No. 02 Ganassi car took the lead on the first lap, swapping it well into the night with the No. 01 Ganassi car, the No. 10 Wayne Taylor Racing Corvette DP, and the defending champion No. 5 Action Express Corvette DP, all of them staying within about 20 seconds of one another. The Action Express car had a fuel connector come loose and lost three laps getting towed back to the pits to have it reattached, but was back in the lead 18 hours in. The No. 01 Ganassi car dropped out with recurring clutch problems 22 hours in, retiring not long after. A race-within-the-race is where the concluding action happened, a seven minute, 30-second dash from the end of the last caution to the checkered flag. During the penultimate pit stops with an hour to go, Dixon was in second place followed Jordan Taylor in the Wayne Taylor Racing DP into the pits but beat him out, taking the lead. The Action Express car was in third. In the last pit stops of the race, Dixon gained even more time, getting a four-second advantage over Taylor. Then a full-course caution came out twenty minutes before the finish when a Prototype Challenge car hit the wall and caught fire, bunching up the field. That closed the pits, but the Wayne Taylor Racing car had to pit during that yellow because of a miscalculation of driver time. No driver can be behind the wheel for more than four hours in a six-hour period but Jordan Taylor was going to go over, so he came in to swap out for brother Ricky. That cost the team any chance of second place, since they took an additional drive-through penalty for entering closed pits. When the track went green again, Sebastien Bourdais in the Action Express car stayed all over Dixon for the final five laps but couldn't get around him.

Recharge Wrap-up: EV torque secrets, UC Davis maps future of biofuels

A UC Davis white paper maps out "Three Routes Forward for Biofuels," balancing investment risk with carbon benefits. The first option is "incremental," in which we tinker with the existing biofuel manufacturing infrastructure for small improvements over time. The "transitional" plan suggests integrating cellulosic production and other innovations with existing operations. The third route, called "leapfrogging," would mean building refineries based on new technology such as cellulosic and algae-based biofuels. The paper suggests ways the US could use these three routes together in different areas, and predicts the payoffs in terms of carbon emissions could be significant if the right people are willing to risk the capital. After all, financial advisers are always telling investors to diversify their portfolios to manage risk and rewards in the same way. Read more over at the UC Davis Institute of Transportation Studies. The Formula E Long Beach ePrix will offer free admission. The seventh round of the inaugural all-electric race season, which was moved from Los Angeles to the streets of Long Beach, will offer fans free grandstand and general admission. The race, which takes place on April 5, 2015, will use a 1.6-mile portion of IndyCar's Grand Prix of Long Beach. Read more at LA Times. Polaris is now offering its 2015 GEM electric vehicles, including the new street-legal eM1400 LSV. The passenger and utility vehicles come in two- to six-passenger configurations, many of which are street legal on roads with posted speed limits of up to 35 miles per hour. The eM1400 LSV utility vehicle seats two, offers 1,250 pounds of payload, 1,250 pounds of towing capacity, a top speed of 25 mph and a range of up to 45 miles. Its on-board charger plugs into any standard 110-volt outlet. Read more at Hybrid Cars and check out all the different configurations yourself at the Polaris website. In EVs, more torque does not always equal faster. Green Car Reports found this out when driving the Fiat 500e (with 147 pound-feet) against the similarly weighted Chevrolet Spark EV (with 400 pound-feet). The secret is, at least in part, in the gearing. The Fiat has a 9.6:1 reduction gear, making it quicker at lower speeds despite having far less available torque, while the Chevy uses a 3:1 ratio. The trade-off though, is in top speed. Furthermore, Chevy electronically limits the torque delivery at low speeds, as 400 pound-feet is a lot of launch for the little Spark EV to handle.