1967 Chevrolet Chevelle 502 Big Block V8 on 2040-cars

Auto blog

New Takata problem results in recall of 414 GM vehicles

An airbag-inflator rupture discovered by Takata during testing has resulted in a new recall affecting 414 vehicles from General Motors, including 395 of them in the US. This latest campaign covers 2015 model-year examples of the Buick LaCrosse, Cadillac XTS, Chevrolet Camaro, Equinox, Malibu, and GMC Terrain. There are no reported breaks in any of these vehicles on the road, and the company estimates only one percent of them actually have the faulty parts. According to documents submitted to the National Highway Traffic Safety Administration (as a PDF), one side-airbag inflator failed a cold test at -40 Fahrenheit "releasing high pressure gas and propelling the separated components apart." The supplier told GM about the failure the next day. In these vehicles, the safety device might not only burst but the bag could inflate incorrectly, as well. GM and Takata say that a cause is not yet known, but they are "conducting an investigation." GM will begin notifying affected owners via overnight mail on Oct. 19. Dealers will replace the side airbag modules on all of the affected vehicles with new components outside of the suspect lot. All of the removed parts will also be collected for further study. Takata's faulty front airbag inflators have resulted in a serious scandal for the supplier. Initial figures indicated 34 million US vehicles are need of repair, though more recent figures have knocked that down to 23.4 million bad parts in 19.2 million automobiles. GM was already among the dozen automakers with models to fix, and some of its pickups were affected, along with the Saab 9-2X and Pontiac Vibe. GM Statement: General Motors is recalling 395 cars and crossovers in the U.S. because one of the front seat side air bags inflators may be defective. In the event of a deployment, the air bag's inflator may rupture and the air bag may not properly inflate. The rupture could cause metal fragments to strike the vehicle occupants, potentially resulting in serious injury or death. GM is unaware of any incidents involving vehicles with these components, which were part of a lot in which one inflator failed acceptance testing at the supplier. Dealers will replace the side air bag module or modules in affected vehicles. Including Canada, Mexico and exports, the total population of the recall is 414, GM estimates 1 percent of the recalled vehicles may have the defect.

GM Canada recalls 159,240 GMC and Chevy trucks for faulty defroster circuit

General Motors is recalling more than 159,000 2014-2019 Chevrolet Silverado and GMC Sierra pickup trucks in Canada due to a potential fire risk. GM says the rear defroster circuit could overheat on trucks optioned with the power-sliding rear window. Thus far, there is no word on the recall's relation to U.S. vehicles. The recall, found by Automotive News, was posted to Transport Canada on June 28, 2019 with manufacturer recall No. N192220470. Included in the 159,240 vehicles are the 2014-2018 Silverado 1500, the 2015-2019 Silverado HD, the 2014-2018 Silverado LD, the 2014-2018 Sierra 1500, the 2015-2019 Sierra HD, and the 2014-2018 Sierra LD. The notice says the rear defroster circuit, specifically on trucks with the power-sliding rear window, could overheat. Because of its placement, this excess heat could cause melting, smoking, or possibly fire, in the worst case scenario. As of now, there is no official word when GM will initiate the recall and there is no official fix detailed just yet. GM suggests that owners, who will be notified by mail if their vehicles are affected, take their trucks to a dealer to remove the rear window defroster fuse as a stop-gap.  Automotive News contacted GM to find out if the problem is also found in trucks sold in the United States, but no definitive statement was made, as the investigation is reportedly ongoing. We will update this space if American vehicles are found to be included in the problem.

Recharge Wrap-up: BYD unveils 60-ft electric bus, Honda sticking with hybrids in Europe

BYD has debuted a 60-foot electric bus at the American Public Transportation Association Expo in Houston, TX. The Lancaster bus, as it is called, has a 120-passenger capacity and can drive over 170 miles on a single charge. The articulated bus features low floors and no steps, thanks to in-wheel hub motors. BYD also displayed a 40-foot electric bus that drove the 1,500 miles to the show under its own power (recharging along the way, of course). Read more in the press release below. Honda says it will continue to sell hybrids in Europe, despite the fact that it has stopped selling the CR-Z and Insight due to slow sales. "Our focus at the moment is on our 1.6-liter diesel but we haven't forgotten about hybrid technology," says Honda Europe's Philip Ross. Honda will sell the next-generation Fit (badged as the Jazz) in Europe when it launches next summer, and will sell the next-gen hybrid version beginning in 2016. Honda sold 4,500 of the Jazz hybrid in Europe last year. Read more at Automotive News. XL Hybrids is selling its XL3 Hybrid Electric Drive System in California. The news comes after the California Air Resources Board issued an executive order allowing the aftermarket hybrid conversion for 2012-2014 Chevrolet Express and GMC Savana vans. The XL3 Hybrid regenerative braking conversion increases real-world mpg by about 25 percent. Read more in the press release below. NRG eVgo has finished installing 60 charging stations at the Sony Pictures Entertainment studio lot and offices in Culver City, California. The Level 2 chargers, which will be managed by NRG eVgo, allow employees to charge their EVs during the workday. An average of 90 EVs and PHEVs park at the studio headquarters every day, thanks in part to Sony Pictures' Alternative Vehicles Incentive program for its employees. Learn more in the press release below. Pennsylvania's Public Utility Commission will allow operators of EV charging stations to set prices based on kilowatt hour usage. This change ensures that drivers pay for the actual energy they use, rather than the time they spend charging, since different cars can charge at different speeds. Car Charging Group has already begun using the per-kWh fee structure at its charging stations throughout the state. Other states that allow kWh pricing are California, Colorado, Florida, Hawaii, Illinois, Maryland, Minnesota, New York, Oregon, Virginia and Washington. Read more in the press release below.