1993 Chevy Z71 Shortbed Stepside 4x4 Pickup on 2040-cars

Auto blog

How GM engineers are using diaper 'snow' to keep you warm

Testing how snow affects General Motors' vehicles isn't really a problem right now for the company's engineers, but in the dog days of summer the process isn't exactly easy. The only real option is for them to book time at the automaker's climatic wind tunnel. However, a flash of brilliance from an engineer allows snow to be simulated regardless of the temperature outside, and the discovery is all because of his daughter's wet diaper. The realization came to GM Thermal Systems engineer Nicholas Jahn while he was swimming with his daughter and noticed how her diaper ballooned in size in the water. He found out the substance that makes this possible is called sodium polyacrylate. When the material gets wet it grows and forms fluffy flakes that are a close imitation of snow. Best of all, the stuff can be prepared easily any time of the year, and it's reusable. The engineering team uses the material to test the effectiveness of the heating systems of GM's vehicles. They spread the sodium polyacrylate over the inlets at the base of the windshield to obstruct the airflow and then crank the heater. After some time, they can see how much is being sucked into the system and design more efficient systems in the future. See how the process works in the video above and read about the diaper discovery in GM's press release below. Diapers Change Chevy Cruze Winter Warm-up Time GM validation engineer uses diaper material "snow" to reduce frigid drives 2015-01-06 DETROIT – An item commonly found on an infant's changing table is helping General Motors' engineers simulate snow year round, ensuring heating systems in cars like the 2015 Chevrolet Cruze can quickly and efficiently warm its interior. Packed snow can prevent air from entering the inlet panel at the bottom of the windshield, obstructing the flow of air into the heating system and reducing the amount of air it can push out. This can lead to less efficient warming of the car's interior and windshield defrosting. "The last thing anyone wants to do when it's freezing cold out is scrape their windshield," said Nicholas Jahn, GM Vehicle Thermal Systems engineer. "The testing we perform on the Chevrolet Cruze with the diaper material allows us to maximize the car's heating capabilities." Ironically, Jahn stumbled upon his diaper-based testing method in the middle of summer. During a swim with his daughter, he noticed her diaper multiplied in size when it came into contact with water.

Autoblog Minute: VW finds CO2 'irregularities', Takata dropped by automakers, SEMA recap

Volkswagen's diesel emissions scandal gets a new wrinkle, US regulators hit Takata Corporation with a substantial fine, and we head to Las Vegas for a look at tuner paradise at the 2015 SEMA show. Autoblog senior editor Greg Migliore reports on this edition of Autoblog Minute Weekly Recap. Show full video transcript text [00:00:00] Volkswagen's diesel emissions scandal gets a new wrinkle. US regulators issue a significant fine to Takata Corporation. And we take a peek inside tuner paradise at the 2015 SEMA show. I'm senior editor Greg Migliore and this is your Autoblog Minute Weekly Recap. The VW diesel emissions scandal, first brought to light in September, gets a new wrinkle, as an internal investigation by the German automaker revealed [00:00:30] irregularities in CO2 emissions that could affect approximately 800,000 vehicles. VW estimates the issue could pose a 2-billion euro economic risk. VW claims that most of the vehicles affected have diesel engines, but industry analysts say a 1.4-liter gas engine is also affected. VW says that fuel consumption figures were set too low during the CO2 certification process. During all of this, sales of some diesel-powered Volkswagen, Audi, and Porsche models [00:01:00] have been halted. Takata Corporation is back in the news in connection with its deadly airbag scandal. Federal regulators fined Takata $70 million. If the parts supplier does not comply, the fine could balloon to $200 million. Takata was also dropped this week by its biggest customer, Honda. And now, Toyota and Mazda will be following Honda's lead in dropping Takata. We're also hearing that Mitsubishi and Subaru are considering a switch in air-bag inflator suppliers. SEMA 2015 [00:01:30] came and went. We saw offerings from Mopar, like the AWD Challenger concept. Honda unveiled a Ridgeline that it will race at the Baja 1000, which gives us a hint at what future production model could look like. The celebrity presence was also felt in Vegas as it always is. Kid Rock brought a Duramax Diesel Chevy Silverado, and Acura restored and presented Ludacris with his now famous 1993 Acura Legend. Those are the highlights from the week that was. Be sure to come back on Saturday for my full recap, [00:02:00] where I'll have some added insight into Hyundai's foray into the luxury sector. For Autoblog, I'm Greg Migliore. Autoblog Minute is a short-form video news series reporting on all things automotive.

First 2015 Chevy Corvette Z06 Sells For One Million Dollars

NASCAR team owner Rick Hendrick loves buying first-built Chevrolet models for charity. He paid $1 million to buy the first production 2014 Corvette Stingray Convertible and $650,000 to get the first 2014 Chevy Camaro Z/28. Hendrick's latest purchase happened at the Barrett-Jackson auction in Palm Beach where he got into a bidding war to pay $1 million to get the first 2015 Corvette Z06. The bidding came quick with the car reaching $100,000 within 3 seconds and hitting $500,000 in about 35 seconds. The money from the sale was donated to the Karmanos Cancer Institute. Related Gallery Harley Earl's Corvette Up For Auction