1990 Chevy Silverado 4x4 Standard Cab on 2040-cars

Auto blog

GM patent reveals new two-stage turbocharger

Modern turbochargers may be some of the best ever made, but performance is something that engineers are always trying to improve. According to GM Inside News, General Motors (GM) is hoping to alleviate some of the negative aspects of a two-stage turbocharger setup with a newly-patented design. The patent, that was filed on May 19, 2016, reveals a clever bypass system that allows the engine, a four-cylinder unit, to optimize both the low-pressure and high-pressure inlets for its respective functions. According to the filing, a conventional two-stage turbocharger setup is engineered to allow both turbines to operate simultaneously at low and mid engine speeds. At high engine speeds, only the low-pressure turbine works. The setup can't isolate either the low or high pressure side, which can impair low-end performance. GM's new two-stage turbocharger setup looks to eliminate this by linking the high-pressure turbo to the exhaust manifold through the high-pressure inlet duct. The low-pressure turbo is attached to the high-pressure turbo by a low-pressure inlet duct, which is linked to a connecting channel. A single actuator that is housed in the exhaust manifold creates a bypass that can opens the high-pressure inlet or close the connecting channel. Depending on what the engine load and speed is, the ECU guides the actuator—a single rotating spindle with discs corresponding to flanges on the high and low pressure sides—to isolate one of the two turbos. Isolating the turbos allow the respective inlets to be engineered for the best possible fluid dynamic performance. The setup should increase performance and decrease lag. There's no word on what car this setup will make an appearance on, but it will most likely be used in premium vehicles before trickling down to the rest of GM's vehicles. Related Video: News Source: GM Inside News, AutoGuide via GM Authority Cadillac Chevrolet GM Technology Sedan turbo patent engine turbocharging

GM recalling 70k Chevy Malibus, Pontiac G6s over steering issue

A problem with the power steering system in the Chevy Malibu and Pontiac G6 has prompted General Motors and the National Highway Traffic Safety Administration to issue a recall for an estimated 69,633 vehicles. The issue revolves around the electric power steering assist, which could suddenly fail and increase the risk of a crash, especially at low speeds where the power steering is most helpful. The recall affects 2006-2007 Chevy Malibu sedans and Malibu Maxx wagons (specifically those manufactured between April 1, 2006, and June 30, 2006), as well as the Pontiac G6 (which was offered as a sedan, coupe or convertible) from the same model years and manufactured from April 18, 2006, to June 30, 2006. Owners of the affected units can expect to hear from the manufacturer with instructions to bring in their vehicles to their local dealers to have the torque sensors in the power steering system replaced. RECALL Subject : Sudden Loss of Electric Power Steering , 1 INVESTIGATION(S) Report Receipt Date: FEB 04, 2015 NHTSA Campaign Number: 15V064000 Component(s): STEERING Potential Number of Units Affected: 69,633 Manufacturer: General Motors LLC SUMMARY: General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving. CONSEQUENCE: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash. REMEDY: GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V-153 to cover additional vehicles built between April 1, 2006 and June 30, 2006. NOTES: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Recharge Wrap-up: Renault Zoe recall, Proterra buses log 2M miles

Renault is recalling 10,649 examples of its Zoe electric car for potential brake hose failure. Cars built at the company's Flins factory between the Zoe's 2012 introduction and October 6, 2014 - a quarter of all Zoes ever built - are subject to the recall, though no accidents have been reported from rupturing brake lines. Recalled vehicles will have the brake hose positions inspected and, if need be, fixed. Read more from Reuters. Proposed legislation in Massachusetts would make the state even more EV friendly. While the state already encourages EV adoption with a $2,500 rebate incentive, the new bill would give battery electric vehicle drivers HOV lane access. Additionally it would set up a standard building code for EV chargers, and allow EV-only parking spaces. "With decreased gas prices, a 10 percent increase in vehicle miles traveled over the last 20 years, and a carpool rate below the national average, we must address personal vehicle use directly as part of our transportation emissions reduction strategy," says Rep. Frank Smizik. Read more from Teslarati. The New York Daily News has named the 2016 Chevrolet Volt as its "Green Machine of the Year." Seamless operation, peppiness, and a nice suite of equipment make it a top choice for the publication. "The 2016 Chevrolet Volt is all new, inside and out, and takes the plug-in hybrid segment to another level, thanks to its increased EV range, updated cabin, and more efficient gas-powered engine," writes Daily News Autos writer (and all-around good guy) Nick Kurczewski. Honorable mentions go to the Tesla Model S, BMW i3, Toyota Prius, and the hydrogen-powered Toyota Mirai. Read more from the Daily News, or at Clean Technica. Proterra electric buses have accumulated 2 million miles of revenue service. That equals 3,800 tons of carbon emissions that have been prevented and 420,000 gallons of fuel unburned. Proterra says it has 63 buses in service in 15 cities, and that it is ramping up production to meet growing demand. "This latest milestone exemplifies the economic, environmental and civic value of electric mass transit," says Proterra CEO Ryan Popple, "and demonstrates to the transit agencies that diesel - often viewed as a necessary evil - is no longer necessary." Read more at Inside EVs. Evercar, a unique EV carsharing service, has found success in Los Angeles. Evercar bills itself as carsharing for rideshare and delivery drivers.