1955 Chevrolet Belair Convertible on 2040-cars

Auto blog

GM recalling 70k Chevy Malibus, Pontiac G6s over steering issue

A problem with the power steering system in the Chevy Malibu and Pontiac G6 has prompted General Motors and the National Highway Traffic Safety Administration to issue a recall for an estimated 69,633 vehicles. The issue revolves around the electric power steering assist, which could suddenly fail and increase the risk of a crash, especially at low speeds where the power steering is most helpful. The recall affects 2006-2007 Chevy Malibu sedans and Malibu Maxx wagons (specifically those manufactured between April 1, 2006, and June 30, 2006), as well as the Pontiac G6 (which was offered as a sedan, coupe or convertible) from the same model years and manufactured from April 18, 2006, to June 30, 2006. Owners of the affected units can expect to hear from the manufacturer with instructions to bring in their vehicles to their local dealers to have the torque sensors in the power steering system replaced. RECALL Subject : Sudden Loss of Electric Power Steering , 1 INVESTIGATION(S) Report Receipt Date: FEB 04, 2015 NHTSA Campaign Number: 15V064000 Component(s): STEERING Potential Number of Units Affected: 69,633 Manufacturer: General Motors LLC SUMMARY: General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving. CONSEQUENCE: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash. REMEDY: GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V-153 to cover additional vehicles built between April 1, 2006 and June 30, 2006. NOTES: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Recharge Wrap-up: Renault Zoe recall, Proterra buses log 2M miles

Renault is recalling 10,649 examples of its Zoe electric car for potential brake hose failure. Cars built at the company's Flins factory between the Zoe's 2012 introduction and October 6, 2014 - a quarter of all Zoes ever built - are subject to the recall, though no accidents have been reported from rupturing brake lines. Recalled vehicles will have the brake hose positions inspected and, if need be, fixed. Read more from Reuters. Proposed legislation in Massachusetts would make the state even more EV friendly. While the state already encourages EV adoption with a $2,500 rebate incentive, the new bill would give battery electric vehicle drivers HOV lane access. Additionally it would set up a standard building code for EV chargers, and allow EV-only parking spaces. "With decreased gas prices, a 10 percent increase in vehicle miles traveled over the last 20 years, and a carpool rate below the national average, we must address personal vehicle use directly as part of our transportation emissions reduction strategy," says Rep. Frank Smizik. Read more from Teslarati. The New York Daily News has named the 2016 Chevrolet Volt as its "Green Machine of the Year." Seamless operation, peppiness, and a nice suite of equipment make it a top choice for the publication. "The 2016 Chevrolet Volt is all new, inside and out, and takes the plug-in hybrid segment to another level, thanks to its increased EV range, updated cabin, and more efficient gas-powered engine," writes Daily News Autos writer (and all-around good guy) Nick Kurczewski. Honorable mentions go to the Tesla Model S, BMW i3, Toyota Prius, and the hydrogen-powered Toyota Mirai. Read more from the Daily News, or at Clean Technica. Proterra electric buses have accumulated 2 million miles of revenue service. That equals 3,800 tons of carbon emissions that have been prevented and 420,000 gallons of fuel unburned. Proterra says it has 63 buses in service in 15 cities, and that it is ramping up production to meet growing demand. "This latest milestone exemplifies the economic, environmental and civic value of electric mass transit," says Proterra CEO Ryan Popple, "and demonstrates to the transit agencies that diesel - often viewed as a necessary evil - is no longer necessary." Read more at Inside EVs. Evercar, a unique EV carsharing service, has found success in Los Angeles. Evercar bills itself as carsharing for rideshare and delivery drivers.

2015 Chevy Spark will have lighter, smaller battery

As General Motors gets ready to release the 2015 Chevy Spark EV, it is retooling the Brownstown Battery Assembly to build a new battery system for the chirpy little electric car. The new Spark will lose a few pounds and kWh from its lithium-ion pack, but it will keep all of it's performance specs. The current Spark EV uses a 21-kWh lithium-ion battery pack with bits made by A123 Systems (known as B456 Systems during bankruptcy). For the 2015 model, GM is going to build a 19-kWh battery system in-house that will use 192 LG Chem cells. Losing a bit of energy capacity means that the battery system for the 2015 Spark EV will be 86 pounds lighter but it will keep the EPA-rated 82-mile range and 119 MPGe. The 2015 Spark EV also keeps its $26,685 (plus destination) starting price from the 2014 model. The car will once again qualify for a federal tax credit of up to $7,500. LG Chem also supplies the cells for GM's other plug-in vehicles from its facility in Western Michigan. The Brownstown production line currently builds the battery packs for the Chevy Volt, the Opel Ampera and the Cadillac ELR. You can read our first drive of the 2014 Chevy Spark here. Brownstown Battery Assembly Expands Capabilities Will build battery system for 2015 Chevrolet Spark EV 2014-05-14 DETROIT – General Motors will bring all its electric vehicle battery building capabilities in-house with production of battery systems for the 2015 Chevrolet Spark EV at its battery assembly plant in Brownstown, Mich. "Using our in-house engineering and manufacturing expertise enabled us to deliver a battery system that is more efficient and lighter than the 2014 Spark EV without sacrificing range," said Larry Nitz, executive director of GM global transmission and electrification engineering. "Our successful working relationship with LG Chem has allowed us to deliver a new battery system for the Spark EV that helps us to better leverage our economies of scale." A newly designed battery system features an overall storage capacity of 19 kWh and uses 192 lithium ion cells. The cells are produced at LG Chem's plant in Holland, Mich. The battery system weight of 474 lbs. is 86 pounds lighter than the system in the 2014 Spark EV. The Spark EV battery is built on a dedicated production line at Brownstown, which also manufactures complete battery packs for the Chevrolet Volt, Opel Ampera and Cadillac ELR.