Auto blog

Brand new cars are being sold with defective Takata airbags

If you just bought a 2016 Audi TT, 2017 Audi R8, 2016–17 Mitsubishi i-MiEV, or 2016 Volkswagen CC, we have some unsettling news for you. A report provided to a US Senate committee that oversees the US National Highway Traffic Safety Administration (NHTSA) and reported on by Automotive News claims these vehicles were sold with defective Takata airbags. And it gets worse. Toyota and FCA are called out in the report for continuing to build vehicles that will need to be recalled down the line for the same issue. That's not all. The report also states that of the airbags that have been replaced already in the Takata recall campaign, 2.1 million will need to eventually be replaced again. They don't have the drying agent that prevents the degradation of the ammonium nitrate, which can lead to explosions that can destroy the airbag housing and propel metal fragments at occupants. So these airbags are out there already. We're not done yet. There's also a stockpile of about 580,000 airbags waiting to be installed in cars coming in to have their defective airbags replaced. These 580k airbags also don't have the drying agent. They'll need to be replaced down the road, too. A new vehicle with a defective Takata airbag should be safe to drive, but that margin of safety decreases with time. If all this has you spinning around in a frustrated, agitated mess, there's a silver lining that is better than it sounds. So take a breath, run your fingers through your hair, and read on. Our best evidence right now demonstrates that defective Takata airbags – those without the drying agent that prevents humidity from degrading the ammonium nitrate propellant – aren't dangerous yet. It takes a long period of time combined with high humidity for them to reach the point where they can rupture their housing and cause serious injury. It's a matter of years, not days. So a new vehicle with a defective Takata airbag should be safe to drive, but that margin of safety decreases with time – and six years seems to be about as early as the degradation happens in the worst possible scenario. All this is small comfort for the millions of people who just realized their brand-new car has a time bomb installed in the wheel or dashboard, or the owners who waited patiently to have their airbags replaced only to discover that the new airbag is probably defective in the same way (although newer and safer!) as the old one.

Audi R8, Lamborghini Huracan could get twin-charged five-cylinder

Engine downsizing and forced induction are some of the biggest trends in automotive powertrains today because. They offer the chance to reduce emissions and boost fuel economy, while possibly maintaining power. The shift is already happening to performance cars with turbocharged four-cylinders finding their way into the Ford Mustang, Chevrolet Camaro, and future Porsches. Now, there are rumblings of a tiny chance for a similar change coming for the Lamborghini Huracan and Audi R8. Why the new powertrain? China. While the market there might have slowing growth, it's still a major country for auto sales. The annual taxes on cars there also happen to be based on engine displacement, and there's a 40 percent rate on those over 4.0-liters, according to Car and Driver. The obvious answer to this conundrum is to build a smaller displacement, forced induction engine for the R8 and Huracan. Car and Driver points to the new turbocharged and electrically supercharged, 2.5-liter inline five-cylinder from the recent Audi TT Clubsport Turbo concept as a possible solution. Audi's e-turbo technology runs off a 48-volt electrical system and lithium-ion battery to produce a total of 600 horsepower and 479 pound-feet of torque in the prototype. With this mill, horsepower would barely shrink compared to the R8 V10 Plus and Lambo, but it actually makes more peak torque than their 5.2-liter V10s. While this is all theoretically feasible, take the possibility with a big grain of salt for now. According to Car and Driver, Quattro GmbH's Stephan Reil says that there's no work currently underway to fit the twin-charged five-cylinder, "but it has been talked about." That means such a vehicle is likely years away, if ever. In the meantime, a diesel version of the e-turbo setup is on the way the in the SQ7. Related Video:

The skinny on Delphi's autonomous road trip across the United States [w/videos]

Rolling out of an S-shaped curve along Interstate 95, just past Philadelphia International Airport, the final obstacle between the autonomous car and its place in history appeared on the horizon. So far, the ordinary-looking SUV had traversed the United States without incident. It had gone through tunnels and under overpasses. It circled roundabouts and stopped for traffic lights. Now, on the last day of a scheduled nine-day journey, it was poised to become the first autonomous car ever to complete a coast-to-coast road trip. First, it needed to contend with the Girard Point Bridge. Riding in a rear seat, "I saw that bridge coming, and I thought, 'Oh my gosh, this is going to be a grab-the-wheel moment," said Kathy Winter, vice president of software at Delphi Automotive. The car, an unassuming Audi SQ5 nicknamed Roadrunner, had been well-tested. Back in January, a few inebriated pedestrians fell flat in front of the car during a demonstration in Las Vegas. It was the quintessential worst-case scenario, and the car admirably hit the brakes. More than drunken louts, bridges present a sophisticated challenge for the six radar sensors that feed data to the car's internal processors. Instead of sensing solid objects, radar sensors can read the alternating bursts of steel beams and empty space as conflicting information. "They're a radar engineer's worst nightmare," said Jeff Owens, Delphi's chief technology officer. Girard Point Bridge, a blue skeleton of girded steel that spans the Schuylkill River, might be a bigger challenge than most. Traveling across the lower level of its double decks, the autonomous car's radar sensors had to discern between two full sets of trusses. Cross the Schuylkill, and Delphi's engineers felt confident they'd reach their destination: the New York Auto Show. For now, the sternest test of the trip lay directly in front of them. A Data-Mining Adventure Until that point, the toughest part of the journey had been finding an open gas station in El Paso, TX. Trust in the technology had already been established. The main reason Delphi set out on the cross-country venture with a team of six certified drivers and two support vehicles was to capture reams of data. What better way to do that than dusting off the classic American road trip and dragging it into the 21st century? They did exactly that, capturing three terabytes worth of data across 3,400 miles and 15 states.